多晶铁冲击相变的离散元方法研究

doi:10.3969/j.issn.1000-1093.2014.07.011

兵工学报 ›› 2014, Vol. 35 ›› Issue (7): 1009-1015.doi: 10.3969/j.issn.1000-1093.2014.07.011

多晶铁冲击相变的离散元方法研究

刘超，石艺娜，秦承森，梁仙红

（北京应用物理与计算数学研究所，北京 100088）

收稿日期:2013-08-29 修回日期:2013-08-29 上线日期:2014-09-05
通讯作者: 刘超 E-mail:liu_chao@iapcm.ac.cn
作者简介:刘超（1976—），女，副研究员，硕士
基金资助:
国家自然科学基金项目(11202034)；中国工程物理研究院科学技术发展基金项目(2011B0101028、2013B0302055)

Study of Shock-induced Polycrystalline Iron Phase Transition with DEM

LIU Chao, SHI Yi-na, QIN Cheng-sen, LIANG Xian-hong

（Institute of Applied Physics and Computational Mathematics, Beijing 100088, China）

Received:2013-08-29 Revised:2013-08-29 Online:2014-09-05
Contact: LIU Chao E-mail:liu_chao@iapcm.ac.cn

摘要/Abstract

摘要： 采用离散元方法，结合基于无扩散相变的两相模型、热力学相容的自由能函数与有限速率相变动力学方程，模拟了α铁的冲击相变过程。计算得到了铁的相边界及冲击Hugoniot关系，并对多晶铁的冲击相变过程进行了模拟。研究结果表明：冲击波的波面不规则程度随传播距离的增加而增加，大晶粒模型内冲击波前沿的不规则程度更高；多晶金属内的相变为非均匀相变，相变首先发生在晶粒边界处，以指状向晶粒内部生长；对于多晶冲击相变过程进行了统计，得到了冲击相变的局部压力-相变质量份额曲线。

关键词: 爆炸力学, 冲击相变, 离散元方法, 多晶材料

Abstract: Numerical simulations on α-iron and polycrystalline iron are conducted using discrete element method (DEM) combined with undiffused two-phase transition model, thermodynamic consistent free energy function, and phase transition kinetics of relaxation equation. The phase boundary and Hugoniot relation are obtained through numerical simulation. The simulation result of polycrystalline iron shows that the shock-front irregularities rise when the propagation distance of shock wave increases; and the shock-front is more irregular in the coarse grain model than in the fine grain model; the phase transitions in the polycrystalline are heterogeneous, and the transitions are observed first along grain boundaries. The curve of local average pressure and transformed mass fraction is obtained.

Key words: explosion mechanics, shock-induced phase transition, discrete element method, polycrystal

中图分类号:

O313.4

刘超，石艺娜，秦承森，梁仙红. 多晶铁冲击相变的离散元方法研究[J]. 兵工学报, 2014, 35(7): 1009-1015.

LIU Chao, SHI Yi-na, QIN Cheng-sen, LIANG Xian-hong. Study of Shock-induced Polycrystalline Iron Phase Transition with DEM[J]. Acta Armamentarii, 2014, 35(7): 1009-1015.

参考文献

［1］ Bancroft D, Peterson E L, Minshall S. Polymorphism of iron at high pressure[J]. J Appl Phys, 1956, 27(3): 291-298.
[2] Cundall P A. A computer model for simulating progressive large scale movement in block rock system[C]∥Symposium ISRM. Nancy, France: International Society of Rock Mechnics, 1971: 129-136.
[3] Sawamoto Y, Tsubota H, Kasai Y, et al. Analytical studies on local damage to reinforced concrete structures under impact loading by discrete element method [J]. Nucl Eng Des, 1998, 179: 157- 177.
[4] 刘凯欣,高凌天，郑文刚. 混凝土动态破坏过程的数值模拟[J]. 工程力学, 2000（增刊）：470-474.
LIU Kai-xin, GAO Ling-tian, ZHENG Wen-gang. Numerical si-mulation for the concrete failure process under shock loading [J]. Engineering Mechanics, 2000(Suppl)470-474. (in Chinese)
[5] 刘凯欣,高凌天. 离散元法在求解三维冲击动力学问题中的应用[J]. 固体力学学报, 2004, 25(2): 181-185.
LIU Kai-xin, GAO Ling-tian. The application of discrete element method in solving three-dimensional impact dynamics problems [J]. Acta Mechanica Solida Sinica, 2004, 25(2): 181-185. (in Chinese)
[6] Yano K, Horie Y. Discrete-element modeling of shock compression of polycrystalline copper [J]. Phys Rev B, 1999, 59: 13672-13680.
[7] Case S, Horie Y. Mesomechanics of the α-δ transition in iron [J]. J Mech Phys Solids, 2007, 55: 589-614.
[8] 王文强. 离散元方法及其在材料和结构力学响应分析中的应用[D]. 合肥. 中国科学技术大学,2000.
WANG Wen-qiang. Discrete element method and its use in analysis of response of materials and structures [D]. Hefei: University of Science and Technology of China, 2000. (in Chinese)
[9] 于继东, 王文强, 刘仓理, 等. 炸药冲击响应的二维细观离散元模拟[J]. 爆炸与冲击, 2008, 28(6): 488-493.
YU Ji-dong, WANG Wen-qiang, LIU Cang-li,et al. Two-dimensional mesoscale discrete element simulation of shock response of explosives [J]. Explosion and Shock Waves, 2008, 28(6): 488-493. (in Chinese)
[10] Tang Z P, Horie Y, Psakhie S G. Discrete meso-element modeling of shock processes in powders［C］∥High Pressure Shock Compression of Solids Ⅳ, Response of Highly Porous Solid to Shock Loading. N Y: Springer, 1997: 143-176.
[11] Yano K, Horie Y. Mesomechanics of the α-ε transition in iron[J]. International Journal of Plasticity, 2002, 18: 1427-1446.
[12] Forbes J W. Experimental investigation of the kinetics of the shock-induced alpha to epsilon phase transformation in armco iron,WSU-SDL 76-01[R]. Pullman, Washington: Washington State University, 1976: 112-120.
[13] Anderson O L. Equations of state of solids for geophysics and ceramic science[M]. New York: Oxford University, 1995: 195.
[14] Lide D R, Kehiaian H V. CRC handbook of thermophysical and thermodynamical data [M]. US: CRC,1994: 136.
[15] Jephcoat A P, Mao H K, Bell P M. The static compression of iron to 78 GPa with rare gas solids as pressure-transmitting media[J]. J Geophys Res, 1986, 91: 4677-4684.
[16] Giles P M, Longenbach M H, Marder A R. High-pressure α-ε martensitic transformation in iron [J]. J Appl Phys, 1971, 42(11): 4290-4295.
[17] Bundy F P. Pressure-temperature phase diagram of iron to 200 kbar, 900 ℃ [J]. J Appl Phys, 1965, 36(2): 616-620.
[18] Kennedy G C, Newton R C. Solids under pressure [M]. New York, McGrawHill, 1963: 163.
[19] Clougherty E V, Kaufman L. High pressure measurement [M]. Washington, Giadini A A, Lloyd E C, 1963: 152.
[20] Barker L M, Hollenbach R E, Shock wave study of the α^TMε phase transition in iron [J]. J Appl Phys, 1974, 45: 4872-4887.
[21] Brown J M, Fritz J N, Hixson R S. Hugoniot data for iron [J]. J Appl Phys, 2000, 88: 5496-5498.
[22] Wallace D C. Irreversible thermodynamics of flow in solids [J]. Phys Rev B, 1980, 22(4): 1477-1486.
[23] Meyers M A , Carvalho M S. Shock-front irregularities in polycrystalline metals [J]. Mater Sci Eng, 1976, 24: 131-135.
[24] Taylor R D, Pasternak M P, Jeanloz R. Hysteresis in the high pressure transformation of bcc-to hcp-iron [J]. J Appl Phys, 1991, 69(8): 6126-6128.
[25] Boettger J C, Wallace D C. Metastability and dynamics of the shock-induced phase transition in iron [J]. Phys Rev B, 1997, 55: 2840-2849.

[1]	冉春，陈鹏万，李玲，张旺峰. 中高应变率条件下TC18钛合金动态力学行为的实验研究[J]. 兵工学报, 2017, 38(9): 1723-1728.
[2]	陈浩玉，洪仁楷，陈永涛，张世文，任国武，莫俊杰. 用于微层裂物质诊断的小型动量探针技术[J]. 兵工学报, 2017, 38(9): 1729-1735.
[3]	唐廷，周健南. 地震后地下受损拱结构的抗爆炸能力研究[J]. 兵工学报, 2017, 38(9): 1736-1744.
[4]	杨军，李焰，张德志，史国凯，张敏，刘文祥，王昭，熊琛. 光子多普勒测速仪与压杆相结合的冲击波反射压力测试技术[J]. 兵工学报, 2017, 38(7): 1368-1374.
[5]	刘俊，田宙，钟巍，谢淑红. 冲击波作用下单层钢化玻璃抗爆性能的数值模拟研究[J]. 兵工学报, 2017, 38(7): 1402-1408.
[6]	李勇，程远胜，张攀，刘均. 空中爆炸载荷下梯度波纹夹层板抗爆性能仿真研究[J]. 兵工学报, 2017, 38(6): 1131-1139.
[7]	赵天辉，高康华，王明洋，李斌，孙松，郭强. 方形容器爆燃泄放过程中的压力特性实验研究[J]. 兵工学报, 2017, 38(4): 722-727.
[8]	崔云霄，陈鹏万，郭保桥， David A. Cendón，周忠彬. 基于内聚裂纹模型的高聚物粘结炸药模拟材料动态断裂行为研究[J]. 兵工学报, 2017, 38(12): 2379-2385.
[9]	刘坚成，皮爱国，黄风雷. 反弹道斜撞击下自由梁结构响应研究[J]. 兵工学报, 2017, 38(11): 2117-2125.
[10]	武强，张庆明，龙仁荣，龚自正. 含能材料防护屏在球形弹丸超高速撞击下的穿孔特性研究[J]. 兵工学报, 2017, 38(11): 2126-2133.
[11]	任国武，郭昭亮，汤铁钢，苏红梅，温上捷，金山. 高应变率加载下金属柱壳断裂的实验研究[J]. 兵工学报, 2016, 37(1): 77-82.
[12]	崔杰，周塞北，王逸，何宝. 减压条件下竖直边界附近气泡动力学行为数值与实验研究[J]. 兵工学报, 2015, 36(9): 1696-1703.
[13]	任鹏，张伟，刘建华，黄威. 高强度水下爆炸等效冲击波加载特性研究[J]. 兵工学报, 2015, 36(4): 716-722.
[14]	刘庆明，刘丽斌，汪建平，王斌，张云明. 烟酸粉尘云爆炸极限的逻辑回归分析[J]. 兵工学报, 2015, 36(3): 523-529.
[15]	项大林，荣吉利，何轩，刘函，陈鹏万，冯志伟. 基于三维数字图像相关方法的水下冲击载荷作用下铝板动力学响应研究[J]. 兵工学报, 2014, 35(8): 1210-1217.

多晶铁冲击相变的离散元方法研究

Study of Shock-induced Polycrystalline Iron Phase Transition with DEM

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价