Research on the Bore Resistance of Projectile Sabots Based on Conic-chamber Gun

doi:10.3969/j.issn.1000-1093.2012.03.013

Abstract

Abstract: The friction between the rear sabot and bore surface in the rectilinear-chamber phase and the impact resistance between the sabots and bore surface during the projectile squashing in the conic-chamber at a high speed in the conic-chamber phase are analyzed. The mathematical models of resistance are set up based on the special structure of conic-chamber gun and projectile. The resistance-length curve, press-length curve, and velocity-length curve are obtained with the mathematical models. And the calculation results are consistent with the experimental results. The research can provide references for the optimization design of conic-chamber gun’s interior ballistics and projectile’s structure.

Key words: applied mechanics, conic-chamber, sabot, resistance

CLC Number:

TJ012

WEI Ping， HOU Jian， CHEN Ting-feng， WANG Qing. Research on the Bore Resistance of Projectile Sabots Based on Conic-chamber Gun[J]. Acta Armamentarii, 2012, 33(3): 324-328.

References

[1] 芮筱亭.弹丸在膛内运动的研究(一)[J]. 弹箭与制导学报，1987，（1）：1-16.
RUI Xiao-ting. The research on the projectile movements in the bore(1) [J]. Journal of Projectiles，Rockets，Missiles and Guidance，1987，(1):1-16.（in Chinese）
[2] 芮筱亭.弹丸在膛内运动的研究(二)[J]. 弹箭与制导学报，1987，(2):23-38.
RUI Xiao-ting. The research on the projectile movements in the bore(2) [J]. Journal of Projectiles，Rockets，Missiles and Guidance, 1987，(2):23-38.（in Chinese）
[3] 芮筱亭.弹丸在膛内的一般运动微分方程[J].弹道学报，1991，(3):28-36.
RUI Xiao-ting. The general differential equations of projectile moving in bore[J].Journal of Ballistics，1991，(3):28-36.（in Chinese）
[4] 芮筱亭，刘正福，陆毓琪.弹丸在膛内运动的研究[J].兵工学报，1991，12(4):1-6.
RUI Xiao-ting，LIU Zheng-fu，LU Yu-qi. A study on projectile motion in bore [J].Acta Armamentarii，1991，12(4):1-6.（in Chinese）
[5] 芮筱亭，陆毓琪.弹丸在膛内的一般运动规律[J].工程力学，1991，(4):60-67.
RUI Xiao-ting，LU Yu-qi. The general pattern of projectile motion in the bore[J].Engineering Mechanics，1991，(4):60-67（in Chinese）
[6] 侯健, 魏平，李金新.锥膛炮内弹道建模与仿真计算[J].兵工学报，2010，32(4):419-422.
HOU Jian，WEI Ping，LI Jin-xin. Interior ballistics modeling and simulation of conic-chamber gun system[J].Acta Armamentarii，2010，32(4):419-422.（in Chinese）
[7] 余同希，斯壮W J. 塑性结构的动力学模型[M].北京：北京大学出版社，2002：10-13.
YU Tong-xi，Strong W J. Dynamical model of plastic configuration [M]. Beijing：Peking University Press，2002：10-13.（in Chinese）
[8] 周彦煌，王升晨.实用两相流内弹道学[M].北京：兵器工业出版社，1990:110-119.
ZHOU Yan-huang，WANG Sheng-chen. Practical two-phase flow interior ballistics[M].Beijing：The Publishing House of Ordnance Industry，1990:110-119.（in Chinese）
[9] 黄克智，夏之熙，薛明德，等.板壳理论[M].北京：清华大学出版社，1987:181-213.
HUANG Ke-zhi，XIA Zhi-xi，XUE Ming-de，et al. Theory of plate and shells [M].Beijing：Tsinghua University Press，1987:181-213.（in Chinese）

[1]	LI Jing, SUN Xiaoxia, MA Xinglong, ZHU Wenxiang. Heat Transfer and Flow Characteristics of Open-cell Metal Foams [J]. Acta Armamentarii, 2024, 45(1): 122-130.
[2]	WANG Zhe, LIU Peng, CHEN Jing, HUANG Guangyan, ZHANG Hong. Blunt Trauma Resistance of Graphene and Polyethylene-modified Aramid Fabrics under Ballistic Impact [J]. Acta Armamentarii, 2024, 45(1): 35-43.
[3]	ZHOU Guangpan, WANG Rong, WANG Mingyang, DING Jianguo, ZHANG Guokai. Experiment and Numerical Simulation of Explosion Resistance Performance of Main Girder of Self-anchored Suspension Bridge Coated with Polyurea [J]. Acta Armamentarii, 2023, 44(S1): 9-25.
[4]	LIU Yan, WANG Baichuan, YAN Junbo, YAN Zichen, SHI Zhenqing, HUANG Fenglei. Dynamic Response of Honeycomb Sandwich Plate with Negative Poisson’s Ratio under Penetration [J]. Acta Armamentarii, 2023, 44(7): 1938-1953.
[5]	CHEN Huimin, GUO Pengyu, LIU Chengyi, YANG Xu. Modeling and Simulation of Pulsed Laser Ignition Based on Thermal Ignition Mechanism [J]. Acta Armamentarii, 2023, 44(7): 1930-1937.
[6]	LI Furong, RONG Jili, WANG Xi, CHEN Zichao, WEI Zhenqian, ZHAO Zitong. Research on Impact Resistance and Failure Modes of Pyramid Sandwich Panel Subjected to Underwater Explosion [J]. Acta Armamentarii, 2023, 44(7): 1954-1965.
[7]	XU Baorong, ZHANG Jinbao, YAO Ligang, ZOU Tiangang, WAN Li. Study and Validation of Resistance Torque Characteristics of Hydro-Mechanical Comprehensive Transmission Device under Low Temperature Conditions [J]. Acta Armamentarii, 2023, 44(6): 1829-1836.
[8]	YANG Guangrui, WANG Wei, YANG Jianchao, WANG Jianhui, WANG Xing. Blast Resistance of Reinforced Concrete Slabs Strengthened with POZD Coated Corrugated Steel [J]. Acta Armamentarii, 2023, 44(5): 1374-1383.
[9]	SHI Junfei, QIAN Linfang, CHEN Hongbin, FU Jiawei. High-Speed Impact Engraving Characteristics of Cased Telescoped Ammunition [J]. Acta Armamentarii, 2023, 44(3): 656-669.
[10]	NING Jianguo, YANG Shuai, LI Yuhui, XU Xiangzhao. Constitutive Model and Blast Resistance Test of Concrete under Low/Room Temperature Curing [J]. Acta Armamentarii, 2023, 44(10): 2932-2943.
[11]	ZOU Ruping， CHEN Shichao， ZHANG Kun， LI Peng， HUANG Chaofan. A Design Method of Flight Controller for Serialized Air-to-ground Missiles [J]. Acta Armamentarii, 2022, 43(S1): 121-127.
[12]	XU Hui, ZHANG Ruijie, JIANG Mingfei, LIU Kun, WU Zhilin. Effects of Chamber Offset on Dynamic Response of Small-caliber Cased Telescoped Ammunition During Engraving [J]. Acta Armamentarii, 2022, 43(9): 2219-2230.
[13]	TIAN Chao， LI Zhipeng， DONG Yongxiang. Influence of Dwell on Anti-penetration Characteristics of Ceramic Composite Structure [J]. Acta Armamentarii, 2022, 43(5): 1144-1154.
[14]	XU Gancheng, YUAN Weize, CHEN Linheng, LI Chengxue, XIE Xuhu, NIE Mengqi. Seismic Collapse Resitance of NFB700 High-strength Steel Plate [J]. Acta Armamentarii, 2022, 43(2): 391-400.
[15]	CAO Zhanwei, CHEN Xin, FU Bin, XU Xiaoliang, YUAN Ye, MAO Wei, WANG Peixiao, YAO Jun, MEI Jie. Engineering Investigations of Thermal Contact Resistance of C/SiC Composite Materials [J]. Acta Armamentarii, 2022, 43(11): 2897-2904.