基于解析法的电磁发射弹丸内膛磁场分布特性分析

doi:10.3969/j.issn.1000-1093.2016.12.004

兵工学报 ›› 2016, Vol. 37 ›› Issue (12): 2205-2211.doi: 10.3969/j.issn.1000-1093.2016.12.004

基于解析法的电磁发射弹丸内膛磁场分布特性分析

李湘平，鲁军勇，李玉，武晓康

（海军工程大学舰船综合电力技术国防科技重点实验室，湖北武汉 430033）

收稿日期:2016-05-10 修回日期:2016-05-10 上线日期:2017-02-20
作者简介:李湘平(1990—)，男，博士研究生
基金资助:
国家自然科学基金项目（51407191、51307176）；国家“973”计划项目（6132620102）

Analysis of Distribution Characteristics of In-bore Magnetic Field of Electromagnetically Launched Projectile Based on Analytical Method

LI Xiang-ping, LU Jun-yong, LI Yu, WU Xiao-kang

(National Key Laboratory for Vessel Integrated Power System Technology, Naval University of Engineering,Wuhan 430033, Hubei, China)

Received:2016-05-10 Revised:2016-05-10 Online:2017-02-20

摘要/Abstract

摘要： 电磁轨道发射装置膛内的磁场分布特性对制导弹丸的器件布局设计非常重要。对电磁轨道发射装置膛内的强磁场环境进行了分析，基于毕奥-萨伐尔定律推导了考虑弹丸运动位移和电流趋肤深度下膛内磁场的计算公式。通过时谐分析方法并采用数据拟合的方式得到了电感梯度与电流频率和弹丸运动位移的函数关系，用以分析弹丸的内弹道运动特性。采用时频分析方法得到了电流趋肤深度随时间的变化关系，从而建立了弹丸中轴线磁场分布特性求解的三维解析计算模型。以实验室的电磁发射装置为例，采用试验电流数据作为输入，对内膛弹丸处磁场分布特性进行解析计算。结果表明：弹丸中轴线的磁感应频率在450 Hz以下，磁感应强度峰值达到0.4 T，并沿弹丸长度方向迅速衰减，100 mm处的磁场基本降为0. 利用磁探针的测试数据验证了理论计算模型的正确性。

关键词: 兵器科学与技术, 电磁发射, 内膛磁场分析, 毕奥-萨伐尔定律, 电流趋肤效应, 时谐分析, 时频分析

Abstract: The in-bore magnetic field distribution characteristics of electromagnetic launcher should be considered in the layout design of components in guided projectile. The high in-bore magnetic field generated by electromagnetic launcher is analyzed, and a formula for magnetic field distribution is deduced based on Biot-Savart law, in which projectile displacement and current skin depth are considered. The relationship between inductance gradient, current frequency and projectile’s location is obtained by time-harmonic analysis and data fitting to analyze the in-bore kinetic characteristics of projectile interior trajectory. And the time-frequency analysis method is used to achieve the relationship between current skin depth and time to build a 3-D theoretical calculation model (TCM) for the distribution characteristics of magnetic field along the central axis of projectile. A laboratory electromagnetic launcher is taken for example, and the experimental data is used as input for simulation. The results show that the in-bore magnetic induction intensity frequency is below 450 Hz and the peak of in-bore magnetic induction intensity is up to 0.4 T, which gets weaker along the length direction of projectile and approximates to 0 at 100 mm. The validity of TCM is verified by using the experimental data of magnetic probe.

Key words: ordnance science and technology, electromagnetic launch, in-bore magnetic field analysis, Biot-Savart law, current skin effect, time-harmonic analysis, time-frequency analysis

中图分类号:

李湘平，鲁军勇，李玉，武晓康. 基于解析法的电磁发射弹丸内膛磁场分布特性分析[J]. 兵工学报, 2016, 37(12): 2205-2211.

LI Xiang-ping, LU Jun-yong, LI Yu, WU Xiao-kang. Analysis of Distribution Characteristics of In-bore Magnetic Field of Electromagnetically Launched Projectile Based on Analytical Method[J]. Acta Armamentarii, 2016, 37(12): 2205-2211.

参考文献

［1］ Fair H D. Electric launch science and technology in the United States[J]. IEEE Transactions on Magnetics, 2003, 39(1): 11-17.
[2］ Reed J D. Keynote remarks at the 12th symposium on electromagnetic launch technology[J]. IEEE Transactions on Magnetics, 2005, 41(1): 155-157.
[3］ Pencil E J, Kamhawi H, Gilland J H, et al. Overview of advanced electromagnetic propulsion development at NASN Glenn Research Center, NASA/TM-2005-213888[R]. Washington: the NASA Program Office, 2005.
[4］高成，刘晓，石立化, 等. 低频强磁场屏蔽效能的测试方法与测试设备研制[J]. 高电压技术，2010，36(9)：2272-2277.
GAO Cheng, LIU Xiao, SHI Li-hua, et al. Measurement method and measurement equipment development for low-frequency magnetic field[J].High Voltage Engineering, 2010, 36(9): 2272-2277.(in Chinese)
[5］杨玉东，付成芳，薛文, 等.轨道与弹丸间运动电磁场分布的数值计算[J]. 火炮发射与控制学报，2014,35(3): 1-5.
YANG Yu-dong, FU Cheng-fang, XUE Wen, et al. Numerical calculation of movement electromagnetic field distribution between rail and armature[J]. Journal of Gun Launch & Control, 2014, 35(3): 1-5. (in Chinese)
[6］周媛，严萍，袁伟群, 等.电磁轨道发射装置中导轨几何参数对电感梯度的影响[J].电工电能新技术，2009, 28(3): 23-27.
ZHOU Yuan, YAN Ping, YUAN Wei-qun, et al. Effect of rail geometrical parameters on inductance gradient of EML[J]. Advanced Technology of Electrical Engineering and Energy, 2009, 28(3): 23-27. (in Chinese)
[7］ Nie J X, Han J J, Jia Q J, et al. An analytic expression of induction gradient for rail-type electromagnetic launcher [J]. IEEE Transactions on Plasma Science, 2011, 39(3): 931-934.
[8］李迎生. 小口径电磁轨道炮内弹道特性初步研究[D].南京：南京理工大学，2007.
LI Ying-sheng. Primary study on interior ballistics of a small caliber electromagnetically railgun[D]. Nanjing: Nanjing University of Science and Technology, 2007. (in Chinese)
[9］ Geng Y B, Xu L Z. Analysis of projectile motion in bore and transfer efficiency for electromagnetic railgun[C]∥2010 WASE International Conference on Information Engineering (ICIE). Beidaihe, China: IEEE, 2010: 156-160.
[10］ Kong H T, Ji L C, Yuan W Q, et al. Research on interior ballistic mechanics of electromagnetic Railgun [C]∥2012 16th International Symposium on Electromagnetic Launch Technology (EML). Beijing, China: IEEE, 2012.
[11］ Marshall R A, Wang Y. Railguns: their science and technology[M]. Beijing: China Machine Press, 2004: 1-10.
[12］杨玉东，王建新，薛文. 轨道炮动态负载特性的分析与仿真[J].兵工学报，2010, 31(8): 1026-1031.
YANG Yu-dong, WANG Jian-xin, XUE Wen. Simulation and analysis for dynamic load characteristic of railgun[J]. Acta Armamentarii, 2010, 31(8): 1026-1031. (in Chinese)
[13］潘启军，马伟明，赵治华, 等. 磁场测量方法的发展及应用[J]. 电工技术学报, 2005, 20(3): 7-13.
PAN Qi-jun, MA Wei-ming, ZHAO Zhi-hua, et al. Development and application of measurement method for magnetic field[J]. Transactions of China Electrotechnical Society, 2005, 20(3): 7-13. (in Chinese)

[1]	闫晓鹏, 张锦玉, 郝新红, 李剑锋, 代健. 基于多项式Chirplet变换的线性调频引信干扰波形设计方法[J]. 兵工学报, 2024, 45(2): 504-515.
[2]	张嘉炜, 鲁军勇, 谭赛, 李白, 张永胜. 电磁轨道发射装置轨道表面损伤研究现状[J]. 兵工学报, 2023, 44(7): 1908-1919.
[3]	周伯俊, 于传强，刘志浩，柯冰. 基于高压储能的特种车辆快速起竖技术与验证[J]. 兵工学报, 2022, 43(7): 1488-1497.
[4]	高月光，冯顺山，刘云辉，黄岐. 不同端盖厚度的圆柱形装药壳体破片初速分布[J]. 兵工学报, 2022, 43(7): 1527-1536.
[5]	黄伟，杨黎明，史戈宁，张延松，田开文，刘凯. 电磁发射条件下CuCrZr合金材料轨道损伤行为研究[J]. 兵工学报, 2020, 41(5): 858-864.
[6]	王振春，张玉婷，鲍志勇，刘福才，战再吉. 电磁发射磁探针阵列位置分布及姿态优化[J]. 兵工学报, 2020, 41(12): 2408-2416.
[7]	王振春，杨德功，张玉燕. 液压伺服预紧的电磁发射轨道振动频率和幅值特性研究[J]. 兵工学报, 2019, 40(1): 29-34.
[8]	吴笑天，王星，王志鹏，周一鹏，陈游. 基于Fisher判别字典学习的辐射源调制特征识别[J]. 兵工学报, 2018, 39(3): 553-559.
[9]	张永胜，鲁军勇，谭赛，李白，武晓康，娄建勇. 连续电磁发射过程中轨道受力分析[J]. 兵工学报, 2018, 39(3): 618-624.
[10]	邢彦昌，吕庆敖，雷彬，向红军，陈建伟，苑希超. 多匝串联并列轨道炮U形电枢接触界面熔蚀规律分析[J]. 兵工学报, 2018, 39(11): 2081-2091.
[11]	娄伟鹏，郑长松，李和言，陈建文，张周立，马源. 高速《Symbol》v湿式换挡离合器排油阀临界开启和关闭压力研究[J]. 兵工学报, 2017, 38(9): 1665-1672.
[12]	王宪成，杨绍卿，马宁，赵文柱. 车辆柴油机缸套动载荷磨损计算模型研究[J]. 兵工学报, 2017, 38(9): 1673-1680.
[13]	孙皓泽，常天庆，王全东，孔德鹏，戴文君. 一种基于分层多尺度卷积特征提取的坦克装甲目标图像检测方法[J]. 兵工学报, 2017, 38(9): 1681-1691.
[14]	张玉燕，孙莎莎，王振春，曹海要，战再吉. 高速载流电枢表面瞬态温度场仿真与测量[J]. 兵工学报, 2017, 38(9): 1692-1698.
[15]	李臣明，宦超，石怀龙. 某箱式火箭炮对面目标分布式杀伤最优火力分配[J]. 兵工学报, 2017, 38(9): 1699-1704.

基于解析法的电磁发射弹丸内膛磁场分布特性分析

Analysis of Distribution Characteristics of In-bore Magnetic Field of Electromagnetically Launched Projectile Based on Analytical Method

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价