一种基于可靠度约束的分阶段等周期预防性维修模型研究

doi:10.3969/j.issn.1000-1093.2017.11.023

兵工学报 ›› 2017, Vol. 38 ›› Issue (11): 2251-2258.doi: 10.3969/j.issn.1000-1093.2017.11.023

一种基于可靠度约束的分阶段等周期预防性维修模型研究

席启超^1,2，曹继平²，陈桂明²，常雷雷²，熊奇²，王赛²

（1.96717部队，浙江金华 321006； 2.火箭军工程大学装备管理工程系，陕西西安 710025）

收稿日期:2017-04-17 修回日期:2017-04-17 上线日期:2018-01-03
通讯作者: 曹继平（1974—），男，副教授，博士生导师 E-mail:xacjp@sina.com
作者简介:席启超（1986—），男，助理工程师，硕士研究生。 E-mail: 13857993797@163.com
基金资助:
国家自然科学基金项目（71601180）

Research on a Phased Periodic Preventive Maintenance Model Based on Reliability Constraint

XI Qi-chao^1,2, CAO Ji-ping², CHEN Gui-ming², CHANG Lei-lei², XIONG Qi², WANG Sai²

(1.Unit 96717 of PLA, Jinhua 321006, Zhejiang, China; 2.Department of Equipment Management Engineering, Rocket Force University of Engineering, Xi'an 710025, Shaanxi, China)

Received:2017-04-17 Revised:2017-04-17 Online:2018-01-03

摘要/Abstract

摘要： 为保持装备寿命周期的运行可靠性，针对周期预防性维修模型和顺序预防性维修模型的优缺点，结合装备维护保养实际，提出3阶段等周期预防性维修模型。以可靠度约束条件下的装备寿命周期最小费率为优化目标，建立了周期预防性维修模型、顺序预防性维修模型和3阶段等周期预防性维修模型，从而得到各计算模型装备寿命周期的最优预防性维修次数和维修间隔期。结果表明，在同等条件下，3阶段等周期预防性维修模型既能保持装备寿命周期内较高的可靠性和较低的费率，又能紧密结合维修操作实际，具有良好的应用可行性和推广性。

关键词: 兵器科学与技术, 可靠度, 预防性维修, 最小费率, 维修次数, 维修间隔期

Abstract: In order to maintain the operational reliability of equipment during life cycle, the advantages and disadvantages of the periodic preventive maintenance model and the sequential preventive maintenance model are analyzed. A three-stage periodic preventive maintenance model is proposed based on the equipment maintenance practices. Three models, i.e., periodic preventive maintenance model, sequential preventive maintenance model and three-stage periodic preventive maintenance model, are constructed by taking the minimum cost rate of equipment life cycle under the reliability constraints as the optimization objective. The optimal preventive maintenance frequencies and intervals of equipment life cycle of each model are obtained. The case study results show that, under the same conditions, a high reliability and a low cost rate of equipment during life cycle can be obtained by using the three-stage periodic maintenance model. Moreover, it can also closely integrate the maintenance operation practices, as well as has a good feasibility and generalizability. Key

Key words: ordnancescienceandtechnology, reliability, preventivemaintenance, minimumcostrate, maintenancefrequency, maintenanceinterval

中图分类号:

席启超，曹继平，陈桂明，常雷雷，熊奇，王赛. 一种基于可靠度约束的分阶段等周期预防性维修模型研究[J]. 兵工学报, 2017, 38(11): 2251-2258.

XI Qi-chao, CAO Ji-ping, CHEN Gui-ming, CHANG Lei-lei, XIONG Qi, WANG Sai. Research on a Phased Periodic Preventive Maintenance Model Based on Reliability Constraint[J]. Acta Armamentarii, 2017, 38(11): 2251-2258.

参考文献

［1］黄傲林，李庆民，黎铁冰，等. 劣化系统周期预防性维修策略的优化［J］. 系统工程与电子技术，2014，36（6）：1103-1107.
HUANG Ao-lin, LI Qing-min, LI Tie-bing, et al. Optimization of periodic preventive maintenance policies for deterioration repairable system［J］. Systems Engineering and Electronics, 2014, 36(6): 1103-1107. (in Chinese)
［2］ Zhou Q, Sun Y. Imperfect preventive maintenance model study based on reliability limitation［C］∥ Proceedings of the 1st International Conference on Nanomaterial, Semiconductor and Composite Materials. Singapore: EDP Sciences, 2016: 1-3.
［3］ Darghouth M N, Aitkadi D, Chelbi A. Joint reliability based design and periodic preventive maintenance policy for systems sold with warranty［J］. Journal of Quality in Maintenance Engineering, 2016, 22(1):2-17.
［4］ Wang J, Zhou Z, Peng H. Flexible decision models for a two-dimensional warranty policy with periodic preventive maintenance ［J］. Reliability Engineering & System Safety, 2017, 162:14-27.
［5］白冬梅，白永生，韩玉成. 基于二维量度的复杂设备预防性维修决策优化［J］. 火力与指挥控制，2017，42（2）：88-91.
BAI Dong-mei, BAI Yong-sheng, HAN Yu-cheng. Optimization research on two-dimensional preventive maintenance decision of complex devices［J］. Fire Control & Command Control, 2017, 42(2): 88-91. (in Chinese)
［6］盛天文，陈晓慧，易树平. 寿命型设备的预防维修策略研究［J］. 计算机集成制造系统，2009，15（3）：598-603.
SHENG Tian-wen, CHEN Xiao-hui, YI Shu-ping. Preventive maintenance policy for life-type equipment［J］. Computer Integrated Manufacturing Systems, 2009,15(3): 598-603. (in Chinese)
［7］ Sheu S H, Chang C C, Chen Y L. An extended sequential imperfect preventive maintenance model with improvement factors［J］. Communications in Statistics-Theory and Methods, 2012, 41(7):1269-1283.
［8］ El-ferik S, Ben-daya M. Integrated production maintenance model under imperfect age-based maintenance policy and non-negligible maintenance times［J］. Aisa-Pacific Journal of Operational Research, 2010, 27(4): 539-558.
［9］ Khatab A. Hybrid hazard rate model for imperfect preventive maintenance of systems subject to random deterioration［J］. Journal of Intelligent Manufacturing, 2015, 26(3):601-608.
［10］盖京波，孔耀. 有限使用时间内预防性维修策略优化［J］. 兵工学报，2015, 36（11）：2164-2172.
GAI Jing-bo, KONG Yao. Optimization strategy of preventive maintenance in finite time horizon［J］. Acta Armamentarii, 2015, 36(11): 2164-2172. (in Chinese)

［11］刘欢，刘志刚，姜静. 基于可靠度约束的接触网系统预防性维修策略优化研究［J］. 机械强度，2016，38（1）：74-79.
LIU Huan, LIU Zhi-gang, JIANG Jing. Optimization research of preventive maintenance strategy on the catenary system based on reliability constraints［J］. Journal of Mechanical Strength, 2016, 38(1): 74-79. (in Chinese)
［12］韩帮军，范秀敏，马登哲. 基于可靠度约束的预防性维修策略的优化研究［J］. 机械工程学报，2003, 39（6）：102-105.
HAN Bang-jun, FAN Xiu-min, MA Deng-zhe. Research on the optimal preventive maintenance policy based on reliability constraints［J］. Journal of Mechanical Engineering, 2003, 39(6): 102-105. (in Chinese)
［13］王雪琴，杨秀香. 关于连续函数平均值的研究［J］. 渭南师范学院学报，2015，30（10）：22-25.
WANG Xue-qin, YANG Xiu-xiang. Research on the average continuous function［J］. Journal of Weinan Normal University, 2015, 30(10): 22-25. (in Chinese)

［14］ Toshio N. Periodic and sequential preventive maintenance policies［J］. Journal of Applied Probability, 1986, 23(2):536-542.
［15］周晓军，奚立峰，李杰. 一种基于可靠性的设备顺序预防性维护模型［J］. 上海交通大学学报，2005，39（12）：2044-2047.
ZHOU Xiao-jun, XI Li-feng, LEE Jay. A reliability-based sequential preventive maintenance model［J］. Journal of Shanghai Jiao Tong University, 2005, 39(12): 2044-2047. (in Chinese)

第38卷
第11期2017 年11月兵工学报ACTA
ARMAMENTARIIVol.38No.11Nov.2017

[1]	闫理跃, 王厚军, 刘震. 一种结合噪声辅助技术和现场数据的模拟电路实时可靠度预测方法[J]. 兵工学报, 2019, 40(2): 326-333.
[2]	娄伟鹏，郑长松，李和言，陈建文，张周立，马源. 高速《Symbol》v湿式换挡离合器排油阀临界开启和关闭压力研究[J]. 兵工学报, 2017, 38(9): 1665-1672.
[3]	王宪成，杨绍卿，马宁，赵文柱. 车辆柴油机缸套动载荷磨损计算模型研究[J]. 兵工学报, 2017, 38(9): 1673-1680.
[4]	孙皓泽，常天庆，王全东，孔德鹏，戴文君. 一种基于分层多尺度卷积特征提取的坦克装甲目标图像检测方法[J]. 兵工学报, 2017, 38(9): 1681-1691.
[5]	张玉燕，孙莎莎，王振春，曹海要，战再吉. 高速载流电枢表面瞬态温度场仿真与测量[J]. 兵工学报, 2017, 38(9): 1692-1698.
[6]	李臣明，宦超，石怀龙. 某箱式火箭炮对面目标分布式杀伤最优火力分配[J]. 兵工学报, 2017, 38(9): 1699-1704.
[7]	雷娟棉，张嘉炜，谭朝明. 小攻角下船尾外形对旋转弹丸马格努斯效应影响的数值研究[J]. 兵工学报, 2017, 38(9): 1705-1715.
[8]	李泽，闫晓鹏，栗苹，郝新红，王建涛. 扫频式干扰对调频多普勒引信的干扰机理研究[J]. 兵工学报, 2017, 38(9): 1716-1722.
[9]	张浩为，谢军伟，张昭建，宗彬锋，陈唐军. 基于混合自适应遗传算法的相控阵雷达任务调度[J]. 兵工学报, 2017, 38(9): 1761-1770.
[10]	李茂，侯海量，朱锡，黄晓明，李典，陈长海，胡年明. 结构间隙对芳纶纤维增强复合装甲结构抗侵彻性能的影响[J]. 兵工学报, 2017, 38(9): 1797-1805.
[11]	王鉴, 韩焱, 王黎明, 张丕状, 陈平. 弹丸在膛内运动的回波信号瞬时频率估计方法研究[J]. 兵工学报, 2017, 38(9): 1806-1814.
[12]	刘海鸥，张文胜，徐宜，赵梓烨. 基于核密度估计的履带车辆传动轴载荷谱编制[J]. 兵工学报, 2017, 38(9): 1830-1838.
[13]	姜缪文，闫健卓，陈继民. 基于拓扑优化技术的军用头盔内胆结构三维打印[J]. 兵工学报, 2017, 38(9): 1845-1853.
[14]	张磊，李世民，朱刚. 基于时间连续灰色Markov模型的维修器材需求预测方法研究[J]. 兵工学报, 2017, 38(9): 1862-1866.
[15]	张亚舟，李贞晓，程年恺，田慧，栗保明. 一种真空触发开关脉冲电源系统研究[J]. 兵工学报, 2017, 38(8): 1469-1475.

一种基于可靠度约束的分阶段等周期预防性维修模型研究

Research on a Phased Periodic Preventive Maintenance Model Based on Reliability Constraint

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价