滚/滑接触下一种航天润滑油4129摩擦特性及黏温特性研究

doi:10.3969/j.issn.1000-1093.2014.09.027

兵工学报 ›› 2014, Vol. 35 ›› Issue (9): 1515-1520.doi: 10.3969/j.issn.1000-1093.2014.09.027

• 研究简报 • 上一篇

滚/滑接触下一种航天润滑油4129摩擦特性及黏温特性研究

王燕霜^1,2，曹佳伟²，李航², 李璞²

（1.天津职业技术师范大学机械工程学院，天津 300222； 2.河南科技大学机电工程学院, 河南洛阳 471003）

收稿日期:2013-11-18 修回日期:2013-11-18 上线日期:2014-11-03
作者简介:王燕霜（1972—），女，教授，硕士生导师
基金资助:
国家自然科学基金项目（51105131）；河南省科技创新杰出青年基金项目(124100510002)；河南省高校创新人才项目（2011HASTIT016）

Study of Frictional and Viscosity-temperature Characteristics of a Space Lubricating Oil No.4129 in Rolling/sliding Contact

WANG Yan-shuang^1，2, CAO Jia-wei², LI Hang², LI Pu²

(1.College of Mechanical Engineering, Tianjin University of Technology and Education, Tianjin 300222, China；2.School of Mechatronics Engineering, Henan University of Science and Technology, Luoyang 471003, Henan, China)

Received:2013-11-18 Revised:2013-11-18 Online:2014-11-03

摘要/Abstract

摘要： 在自行研制的模拟航天轴承的摩擦力试验机上，对4129航天润滑油进行了摩擦特性分析。对该润滑油在实际高低温工况下的黏度进行了测量。分析了温度、滚动速度和滑动速度与该油摩擦系数的关系，建立了该航天润滑油的黏温模型、摩擦系数计算模型。研究结果表明：当温度小于0 ℃时，4129航天润滑油黏度随温度的变化非常大；温度大于30 ℃时，其黏度随温度的变化较小。当滑动速度小于0.3 m/s时，该油摩擦系数随滑动速度近似线性增加；当滑动速度大于0.3 m/s时，摩擦系数随着滑动速度的增加呈非线性增加；当滑动速度大于1 m/s之后，摩擦系数随滑动速度增加基本保持不变。摩擦系数随油温的增加而减小。当滚动速度从1 m/s增加到3 m/s时，油的摩擦系数迅速下降，随着滚动速度继续增加，摩擦系数下降缓慢直到达到最小值，然后基本保持不变。

关键词: 航空、航天材料, 航天轴承, 航天润滑油, 黏温特性, 摩擦特性

Abstract: The frictional characteristics of a space lubricating oil No.4129 are tested by using the self-made friction test rig which can simulate the frictional characteristics of aerospace bearing. The viscosity of this oil is measured by the kinematical viscometer at the high and low temperatures. The effects of the temperature, rolling speed and sliding speed on the friction coefficient are analyzed. A viscosity-temperature model and a frictional characteristic model are established. The results show that its viscosity varies considerably when the temperature is below 0 ℃, and its viscosity varies slowly when the temperature is above 30 ℃. When the sliding speed is less than 0.3 m/s, the friction coefficient of this oil varies linearly with the sliding speed. When the sliding speed surpasses 0.3 m/s, the friction coefficient varies non-linearly with the sliding speed. When the sliding speed surpasses 1 m/s, the friction coefficient remains about the same with the increase in sliding speed. The friction coefficient decreases with the increase in temperture. When the rolling speed increases from 1 m/s to 3 m/s, the friction coefficient decreases quickly. Then the friction coefficient decreases slowly until it reaches the minimum value and keeps unchanged with the increase in rolling speed.

Key words: material of aviation and aerospace, space bearing, space lubricating oil, viscosity-temperature characteristic, friction characteristic

中图分类号:

TH117

王燕霜，曹佳伟，李航, 李璞. 滚/滑接触下一种航天润滑油4129摩擦特性及黏温特性研究[J]. 兵工学报, 2014, 35(9): 1515-1520.

WANG Yan-shuang, CAO Jia-wei, LI Hang, LI Pu. Study of Frictional and Viscosity-temperature Characteristics of a Space Lubricating Oil No.4129 in Rolling/sliding Contact[J]. Acta Armamentarii, 2014, 35(9): 1515-1520.

参考文献

［1］郭峰,黄柏林,付忠学. 界面滑移条件下弹流油膜的试验观察[J]. 机械工程学报,2007，43(10):36-40.
GUO Feng, HUANG Bo-lin, FU Zhong-xue. Experiment observation of elastohydrodynamic lubrication films under conditions of wall slippage[J]. Chinese Journal of Mechanical Engineering, 2007，43(10):36-40. (in Chinese)
[2] 贾超,郭峰,付忠学. 界面滑移条件下点接触Stribeck曲线的实验研究[J]. 润滑与密封，2010,35(1)：33-36.
JIA Chao, GUO Feng, FU Zhong-xue. Experimental study on the stribeck curve of EHL contacts under conditions of wall slippage[J]. Lubrication Engineering, 2010,35(1):33-36. (in Chinese) (in Chinese)
[3] Pepper S V, Kingsbury E. Spiral orbit tribometry-part Ⅰ: description of the tribometer[J]. Tribology Transaction, 2003,46(1): 57-64.
[4] Pepper S V, Kingsbury E. Spiral orbit tribometry-part Ⅱ: evaluation of three liquid lubricants in vacuum[J]. Tribology Transaction, 2003,46(1):65-69.
[5] Lafountain A R, Johnston G J, Spikes H A. The Elastohydrodynamic traction of synthetic base oil blends[J]. Tribology Transactions, 2001, 44(4):648-656.
[6] Querlioz E, Ville F, Lenon H, et al. Experimental investigations on the contact fatigue life under starved conditions[J]. Tribology International, 2007,40(10): 1619-1626.
[7] 李兴虎,赵晓静. 润滑油粘度的影响因素分析[J]. 润滑油,2009,24(6):59-64.
LI Xing-hu, ZHAO Xiao-jing. Analysis offactors affecting lubricant viscosity[J]. Lubricating Oil, 2009,24(6):59-64. (in Chinese)
[8] 王燕霜,徐红玉,杨伯原，等. HKD-1型航空润滑油的粘温特性[J]. 河南科技大学学报,2005,2（4）:28-29.
WANG Yan-shaung, XU Hong-yu, YANG Bo-yuan, et al. Viscosity-temperature characteristic of HKD aviation lubricating oil[J]. Journal of Henan University of Science and Technology, 2005,2（4）: 28-29. (in Chinese)
[9] 王燕霜，邓四二，杨海生，等. 滚/滑接触中HKD航空润滑油拖动特性试验研究[J]. 兵工学报,2009,30(7)：958-961.
WANG Yan-shuang, DENG Si-er, YANG Hai-sheng, et al. Analysis for traction characteristics of HKD aviation lubricating oil in rolling/sliding contacts[J]. Acta Armamentarii, 2009,30(7)：958-961. (in Chinese)
[10] 王燕霜,杨伯原,王黎钦. 两种航空润滑油运动粘度的实验测定［J］. 河南科技大学学报,2004,25(6):13-15.
WANG Yan-shuang, YANG Bo-yuan, WANG Li-qin. Experiment on kinematical viscosity of two aviation lubricating oils[J]. Journal of Henan University of Science and Technology, 2004,25(6): 13-15. (in Chinese)
[11] 温诗铸,黄平. 摩擦学原理［M］. 第3版. 北京;清华大学出版社，1990.
WEN Shi-zhu, HUANG Ping. Principle of tribology [M]. 3rd ed. Beijing: Tsinghua University Press, 1990. (in Chinese)
[12] 孟庆中，杨伯原. 用T-J模型分析新型高速航空润滑油的拖动特性[J]. 机械设计与制造，2006(3)：9-11.
MENG Qing-zhong, YANG Bo-yuan. The analysis of traction behavior of the new type high-speedaerial lubricating oil by the T-J model[J]. Machinery Design and Manufacture,2006(3)：9-11. (in Chinese)
[13] 王燕霜,杨伯原,王黎钦，等. 4106航空润滑油拖动特性研究[J]. 摩擦学学报，2004,24(2)：156-159.
WANG Yan-shuang, YANG Bo-yuan, WANG Li-qin, et al. Traction behavior of 4103 aviation lubricating oil[J]. Tribology, 2004,24(2)：156-159. (in Chinese)
[14] 陈国定,王步瀛,周鸿，等. 滚滑接触状态下合成润滑油牵引特性分析[J]. 西北工业大学学报,1992,10(3):330-335.
CHEN Guo-ding, WANG Bu-ying, ZHOU Hong, et al. On the traction characteristics analysis of synthetic lubricants in rolling/sliding cantacts[J]. Journal of Northwestern Polytechnical University, 1992, 10(3):330-335. (in Chinese)

[1]	王蔚, 沈杰, 刘伟军, 邢飞, 张凯, 李强, 于兴福. 激光清洗中振镜扫描速度对7075铝合金表面质量和摩擦特性的影响[J]. 兵工学报, 2023, 44(10): 2995-3005.
[2]	韩小霞, 冯永保, 谢建, 魏列江, 王亚强, 魏小玲. 考虑油液黏温特性的电静液作动器流量死区动态逆补偿方法[J]. 兵工学报, 2022, 43(2): 316-327.
[3]	宁峰平，陈然，夭银银，樊晓琴，梁晶晶. 预紧力与装配偏差对航天轴承摩擦力矩的影响研究[J]. 兵工学报, 2018, 39(7): 1436-1442.
[4]	赵二辉，马彪，李和言，杜秋，李慧珠，马成男. 转速对湿式离合器局部润滑及摩擦特性影响研究[J]. 兵工学报, 2017, 38(4): 625-633.

滚/滑接触下一种航天润滑油4129摩擦特性及黏温特性研究

Study of Frictional and Viscosity-temperature Characteristics of a Space Lubricating Oil No.4129 in Rolling/sliding Contact

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价