Evaluation Index of Disturbance Superposition Degree in Multi-layer Penetration Acceleration Signal

doi:10.3969/j.issn.1000-1093.2022.01.003

Abstract

Abstract: The evaluation indexes of layer and inter-layer coefficients for the signal superposition degree is presented to solve lack of measurement criterion of inter-layer superposition in multi-layer penetration acceleration signal. The test and simulated signals are segmented by penetration layers. The layer and inter-layer coefficients of acceleration signal for each layer are calculated by subtracting every amplitude of signal points by former one and summing the absolute values of difference values. The larger the two sets of evaluation indexes are, the more severer the superposition degree is. The calculated results of test and simulated signals are used to demonstrate the efficiency of evaluation indexes. The calculated results of layer and inter-layer coefficients in 3 sets of data show that the layer and inter-layer coefficients are smaller if the disturbance superposition degree is lower, and vice versa. One set of data is extracted from the calculated results of evaluation indexes of acceleration signal for two detonation control circuits in one penetration warhead, and the calculated deviation is less 5%. The calculated result is consistent to the results of qualitative analysis and spectral analysis. The experimental results show that the layer and inter-layer coefficients are efficient for evaluating the disturbance superposition degree in multi-layer penetration acceleration signal.

Key words: penetrationfuze, disturbancesignal, superpositiondegree, evaluationindex

CLC Number:

TJ430.2

MA Mengxin， LI Rong, NIU Lanjie. Evaluation Index of Disturbance Superposition Degree in Multi-layer Penetration Acceleration Signal[J]. Acta Armamentarii, 2022, 43(1): 20-28.

References

［1］李蓉, 戴黎红, 吴敏忠, 等.超高速侵彻引信多层目标过载层间粘连机理[J]. 探测与控制学报, 2020, 42(2):1-4,9.
LI R, DAI L H, WU M Z, et al. Adhesion mechanism of multi-layer target overload in hypervelocity penetration fuze [J]. Journal of Detection & Control, 2020,42(2):1-4, 9. (in Chinese)
[2］赵海峰, 张亚, 李世中,等. 基于奇异值分解的侵彻过载信号降噪方法[J].探测、测试与诊断,2015,35(4):770-776.
ZHAO H F, ZHANG Y, LI S Z, et al.Research of the penetration overload signals de-noising method based on singular value decomposition[J].Journal of Vibration, Measurement & Diagnosis,2015,35(4):770-776. (in Chinese)
[3］于润详, 石庚辰. 硬目标侵彻引信计层技术现状与展望[J].探测与控制学报,2013,35(5):1-6.
YU R X, SHI G C. Development and situation of multi-layer hard target penetration fuze [J]. Journal of Detection & Control,2013,35(5):1-6. (in Chinese)
[4］游金川, 李东杰, 欧阳科,等. 侵彻引信炸点精确控制技术[J].中国惯性技术学报,2016,24(1):114-118.
YOU J C, LI D J, OU Y K, et al. Precise detonating-control technique for hard-target penetration fuze[J].Journal of Chinese Inertial Technology,2016,24(1):114-118. (in Chinese)
[5］孙倩华, 孙凯, 张韩宇. 基于盒差分滤波的侵彻引信计层信号预处理方法[J].探测与控制学报,2020,42(5):27-30.
SUN Q H, SUN K, ZHANG H Y. An acceleration signal preprocessing method based on difference of boxes filter[J]. Journal of Detection & Control,2020,42(5):27-30. (in Chinese)
[6］李豪杰, 胡怀春. 基于侵彻过载数值仿真的引信计层起爆控制方法[J].南京理工大学学报,2016,40(6):715-719.
LI H J, HU H C. Layer counting detonating control method for fuze based on penetration overload numerical simulation [J]. Journal of Nanjing University of Science and Technology,2016,40(6): 715-719. (in Chinese)
[7］王燕, 马铁华, 徐鹏, 等. 基于 Choi_Williams分布的侵彻层数识别方法[J]. 爆炸与冲击, 2015, 35(5):758-762.
WANG Y, MA T H, XU P, et al. Identification of penetration layers based on Choi-Williams distribution [J]. Explosion and Shock Waves, 2015, 35(5):758-762. (in Chinese)
[8］黄莎玲, 朱鸿志, 程翔利,等. 基于自适应阈值侵彻引信层目标识别算法研究[J].兵工学报,2020,41(9):1762-1771.
HUANG S L, ZHU H Z, CHENG X L, et al.Adaptive threshold setting method for layer-count in penetration fuze [J]. Acta Armamentarii,2020,41(9): 1762-1771.(in Chinese)
[9］郭晓雪, 张亚, 李世中,等. 基于伪自相关的侵彻数据处理方法[J].探测与控制学报,2012,34(6):45-48.
GUO X X, ZHANG Y, LI S Z, et al. Penetration data processing based on pseudo autocorrelation [J].Journal of Detection & Control,2012,34(6):45-48. (in Chinese)
[10］程祥利, 刘波, 赵慧,等.侵彻战斗部－引信系统动力学建模与仿真[J]. 兵工学报,2020,41(4): 625-633.
CHENG X L, LIU B, ZHAO H, et al. Dynamic modeling and simulation for penetration warhead-fuze system[J]. Acta Armamentarii,2020,41(4): 625-633.(in Chinese)
[11］张爽, 武海军, 黄风雷. 刚性弹正侵彻钢筋混凝土靶阻力模型[J]. 兵工学报,2017,38(11): 2081-2092.
ZHANG S, WU H J, HUANG F L.Resistance model of rigid projectile penetrating into the reinforced concrete target [J]. Acta Armamentarii,2017,38(11): 2081-2092.(in Chinese)
[12］满晓飞, 张合, 马少杰,等. 侵彻引信计层起爆炸点控制实物模拟实验方法研究[J]. 兵工学报,2014,35(10): 1556-1561.
MAN X F, ZHANG H, MA S J, et al. Study of physical simulation experiment of penetration fuze layer-count burst point control [J]. Acta Armamentarii,2014,35(10):1556-1561. (in Chinese)
[13］张冬梅, 高世桥, 李世中.侵彻过程中弹引系统的冲击传递特性研究[J].兵器装备工程学报,2020,41(12):27-34.
ZHANG D M, GAO S Q, LI S Z. Study on impact transfer characteristics of projectile system during penetration[J]. Journal of Ordnance Equipment Engineering,2020,41(12):27-34. (in Chinese)
[14］邓佳杰, 张先锋, 刘闯,等. 头部非对称刻槽弹体侵彻混凝土目标性能研究[J].兵工学报,2018,39(7): 1249-1258.
DENG J J, ZHANG X F, LIU C, et al. Research on penetration of asymmetrically grooved nose projectile into concrete target [J]. Acta Armamentarii,2018,39(7): 1249-1258.(in Chinese)
[15］武海军, 黄风雷, 王一楠,等. 高速侵彻混凝土弹体头部侵蚀终点效应实验研究[J]. 兵工学报,2012,33(1): 48-55.
WU H J, HUANG F L, WANG Y N, et al. Experimental investigation on projectile nose eroding effect of high-velocity penetration into concrete [J]. Acta Armamentarii,2012,33(1): 48-55.(in Chinese)
[16］吴广, 冯顺山, 董永香, 等. 不同硬度弹丸对中厚靶板作用的实验研究[J].兵工学报, 2010, 3l(增刊1):260-263.
WU G, FENG S S, DONG Y X, et al. Experimental study on penetration effects of projectiles with different hardnesses on thick target plate[J]. Acta Armamentarii, 2010, 31(S1):260-263.(in Chinese)
[17］康敬欣, 李科杰, 宋萍. 硬目标侵彻引信虚拟试验技术及其应用[J]. 弹箭与制导学报, 2002, 22(4): 28-31.
KANG J X, LI K J, SONG P.The virtual testing technique of hard-target penetration fuse [J]. Journal of Projectiles, Rockets, Missiles and Guidance, 2002, 22(4): 28-31.(in Chinese)
[18］张志安, 陈荷娟. 硬目标侵彻引信半实物仿真关键技术研究[J]. 计算机仿真, 2008, 25(3):17-20.
ZHANG Z A, CHEN H J. Research on the key technology for hardware-in-the-loop simulation of hard target penetration fuze [J]. Computer Simulation, 2008, 25(3): 17-20.(in Chinese)

[1]	QIN Guohua， GAO Jie， YE Haichao， JIANG Guojie， HUANG Shuai， LAI Xiaochuun. Tool Wear Prediction Based on Fusion Evaluation Index and Neural Network [J]. Acta Armamentarii, 2021, 42(9): 2013-2023.
[2]	FU Binhe, LIU Xixia, LIU Weiping, ZHANG Chuanqing, SONG Haijun. Research on Evaluation Index of Military Vehicle Crew's Information Operation Aptitude under Different Task Demands [J]. Acta Armamentarii, 2020, 41(2): 239-245.
[3]	ZHANG Xiongxing， ZOU Jinlong， WANG Wei， SU Siyou. Research on a Novel Magnetic Sensitive Layer-counting Method for Penetration [J]. Acta Armamentarii, 2019, 40(11): 2204-2211.