Design and Research of the Fast Rise Time Electromagnetic Pulse Protection Module Based on PIN Diode

doi:10.3969/j.issn.1000-1093.2018.10.021

Abstract

Abstract: The fast rise time electromagnetic pulse (FREMP) is an important cause of damage to electronic equipment, and the PIN diode can effectively suppress electromagnetic pulse. In order to investigate the transient response of PIN diodes to FREMP, a time-domain equivalent circuit model based on PIN diodes is adopted. And the transient voltage characteristic of PIN diode circuit under the effect of FREMP is analyzed. Considering the parasitic components of PIN diodes and the bonding wire inductance, the whole physical structure of FREMP protection module is set up based on Butterworth low pass filter model. A FREMP protection module is realized. The measured insertion loss of protection module is lower than 0.38 dB in 1-250 MHz. At large signal condition with input square wave pulse of 4 000 V, the response time is less than 2 ns and the output level is lower than 30 V, which meets the protection requirement of FREMP. Key

Key words: fastrisetimeelectromagneticpulse, PINdiode, spikeleakage, protectionmodule

CLC Number:

O441.5

LI Ya-nan, TAN Zhi-liang. Design and Research of the Fast Rise Time Electromagnetic Pulse Protection Module Based on PIN Diode[J]. Acta Armamentarii, 2018, 39(10): 2066-2072.

References

［1］张子剑, 陈曦, 李茜华, 等. 强电磁脉冲上升时间对RS触发器损伤阈值仿真分析［J］. 强激光与粒子束, 2017, 29(8): 55-60.
ZHANG Zi-jian, CHEN Xi, LI Qian-hua, et al. Simulation analysis of strong electromagnetic pulse rise time on damage threshold of RS flip-flop［J］. High Power Laser and Particle Beams, 2017, 29(8): 55-60. (in Chinese)
［2］ Montano R, Edirisinghe M, Cooray V, et al. Behavior of low-voltage surge protective devices under high-current derivative impulses［J］. Transactions on Power Delivery, 2007, 22(4): 2185-2190.
［3］ IEC 61000-4-2:2001 Electromagnetic compatibility (EMC)-Part 4: testing and measurement techniques-Section 24: test methods for protective devices for HEMP conducted disturbance［S］. Swit- zerland: IEC TC, 1997.
［4］王晨. 射频前端强电磁脉冲防护方法研究［D］. 长沙:国防科学技术大学, 2013: 7-11.
WANG Chen. Study of the strong electromagnetic pulse protection method for RF front-end［D］. Changsha：National University of Defense Technology, 2013: 7-11. (in Chinese)
［5］颜克文. 短波通信设备电磁防护技术研究［D］. 成都:电子科技大学, 2009:43-51.
YAN Ke-wen. Research on electromagnetic protection technology of short wave communication equipment［D］. Chengdu:University of Electronic Science and Technology of China, 2009:43-51.(in Chinese)
［6］郑生全, 邓峰, 王冬冬, 等. 电子设备和系统射频通道高功率微波电磁脉冲场-路综合防护方法综述［J］. 中国舰船研究, 2015, 10(2):7-13.
ZHENG Sheng-quan, DENG Feng, WANG Dong-dong, et al. Overview of the HPM field-circuit integrated protection methods for electronic equipment and system RF-channels［J］. Chinese Journal of Ship Research, 2015, 10(2):7-13. (in Chinese)
［7］谭志良, 刘尚合. 电子设备高功率电磁辐照效应［J］.高电压技术, 2005, 31(10):33-35.
TAN Zhi-liang, LIU Shang-he. Study of electromagnetic radiation effect on electronic equipment［J］. High Voltage Engineering, 2005, 31(10): 33-35.(in Chinese)
［8］张俊, 姜彦南, 张耀辉, 等. 纳秒脉冲下典型钳压型浪涌防护元件的响应特性［J］. 强激光与粒子束, 2016, 28(12): 131-136.
ZHANG Jun, JIANG Yan-nan, ZHANG Yao-hui, et al. Nanosecond pulse response of typical voltage-clamping surge protective devices［J］. High Power Laser and Particle Beams, 2016, 28(12): 131-136.(in Chinese)
［9］张希军, 杨洁, 张庆海. 瞬态电压抑制器在快上升沿电磁脉冲作用下的瞬态响应［J］. 高电压技术, 2012, 38(9):2242-2247.
ZHANG Xi-jun, YANG Jie, ZHANG Qing-hai. Transient response of transient voltage suppressor device under EMP with fast rise time［J］. High Voltage Engineering, 2012, 38(9):2242-2247. (in Chinese)

［10］ Caverly R H, Drozdovski N V, Drozdovskaia L M. SPICE modeling of microwave and RF control diodes［C］∥Proceedings of the 43th IEEE Midwest Symposium on the Circuits and Systems. Lansing, MI, US: IEEE, 2000: 28-31.
［11］陆凡. PIN二极管限幅器的瞬态电热耦合分析［D］. 南京：南京理工大学, 2015:48-51.
LU Fan. Transient electro-thermal coupling analysis of PIN diode limiter［D］. Nanjing:Nanjing University of Science and Technology, 2015:48-51. (in Chinese)
［12］刘国靖, 刘国至, 潘泉, 等. 高功率微波短脉冲雷达接收机保护装置设计［J］. 西安电子科技大学学报, 2002, 29(2):236-240.
LIU Guo-jing, LIU Guo-zhi, PAN Quan, et al. The fundamental design of HPM short-pulse radar receiver protectors［J］. Journal of Xidian University, 2002, 29(2):236-240.(in Chinese)
［13］张亚舟, 李贞晓, 田慧, 等. 基于反向开关晶体管的脉冲电源在电磁发射中的应用［J］. 兵工学报, 2017, 38(4): 658-662.
ZHANG Ya-zhou, LI Zhen-xiao, TIAN Hui, et al. Application of pulse power supply with RSD switch in electromagnetic launch［J］. Acta Armamentarii, 2017, 38(4): 658-662.(in Chinese)
［14］丁家峰. PIN二极管的物理机制、仿真模型及其应用研究［D］. 长沙:中南大学, 2001:13-14.
DING Jia-feng. Studies on mechanism, simulation models and applications of the PIN diode［D］. Changsha:Central South University, 2001:13-14. (in Chinese)
［15］ Kreyasu M, Takashima T. X-band PIN diode limiter with low spike leakage performances using re-entrant coaxial cavity［C］∥Proceedings of 2008 European Conference on Wireless Technology. Fort Worth, TX, US: IEEE, 2008: 735-738.
［16］张海伟, 史小卫. 高功率PIN限幅器设计及测试方案［J］. 强激光与粒子束, 2011, 23(11):3029-3033.
ZHANG Hai-wei, SHI Xiao-wei. High power PIN limiter design and test plan［J］. High Power Laser and Particle Beams, 2011, 23(11):3029-3033. (in Chinese)

第39卷
第10期2018 年10月兵工学报ACTA
ARMAMENTARIIVol.39No.10Oct.2018

[1]	JIA Wen-dou, LIN Chun-sheng, SUN Yu-hui, ZHAI Guo-jun. Location Method of Equivalent Attenuation Magnetic Moment of Magnetic Target in Geomagnetic Field [J]. Acta Armamentarii, 2018, 39(2): 283-289.
[2]	HUANG Liu-hong, HE Yong-sheng, LI Yue-bo, LIU Feng, HE Wei. Influence of Blast Shock on Shielding Effectiveness of Electromagnetic Shielded Enclosure with Integral Shock Isolation [J]. Acta Armamentarii, 2014, 35(12): 2072-2077.
[3]	1：Lu Xincheng, Gong Shenguang, Liu Shengdao；2：Sun Ming. Measurement of Extremely Low Frequency Field Caused by Shaft-Rate Modulated Corrosion Current [J]. Acta Armamentarii, 2004, 25(5): 544-546.