柴油机磁场的计算、试验与消磁优化

doi:10.3969/j.issn.1000-1093.2020.02.017

兵工学报 ›› 2020, Vol. 41 ›› Issue (2): 350-355.doi: 10.3969/j.issn.1000-1093.2020.02.017

柴油机磁场的计算、试验与消磁优化

赵建华¹，应宇辰^1，2，郭成豹³

(1.海军工程大学动力工程学院，湖北武汉 430033；2.海军91202部队，辽宁葫芦岛 125000；3.海军工程大学电气工程学院，湖北武汉 430033)

收稿日期:2019-05-08 修回日期:2019-05-08 上线日期:2020-04-04
作者简介:赵建华(1975—)，男，副教授。E-mail:zhaojh402@sina.com
基金资助:
国家自然科学基金项目（51277176）

CalculationTest and Degaussing Optimization of Magnetic Field in Diesel Engine

ZHAO Jianhua¹， YING Yuchen^1,2， GUO Chengbao³

(1.School of power engineering,Naval University of Engineering, Wuhan 430033, Hubei, China;2.Unit 91202 of PLA Naval, Huludao 125000, Liaoning, China; 3.School of Electrical Engineering, Naval University of Engineering, Wuhan 430033, Hubei， China)

Received:2019-05-08 Revised:2019-05-08 Online:2020-04-04

摘要/Abstract

摘要： 为研究低磁船舶的柴油机磁性及消磁问题，通过柴油机磁场有限元仿真的计算结果来指导消磁工作。利用磁场分析Comsol软件，建立某型柴油机有限元仿真模型，进行地磁场作用下柴油机产生感应磁场及其空间分布的相关计算。引入磁铁抵消消磁法，通过柴油机和消磁磁阵的一体化仿真，进行优化计算，找到最佳消磁参数。结果表明：柴油机下方9 m平面上，正中心位置磁通密度最大，磁场呈椭圆形分布，磁场强度相对地磁场最大畸变量计算值高达224.35 nT，将测量结果与仿真计算结果进行对比，误差不超过5%，在允许的误差范围内；最佳消磁参数可以使柴油机下方9 m平面上的磁场强度畸变量降低至8.33 nT，降低约95%.

关键词: 柴油机磁场, 等效磁荷理论, 有限元方法, 消磁

Abstract: The magnetism and demagnetization of diesel engine of low magnetic ship are studied from the finite element simulation results of magnetic field of diesel engine. A finite element simulation model of a diesel engine is established by using the magnetic analysis COMSOL software, and the strength of induced magnetic field and its spatial distribution are calculated. The degaussing method is used to find the optimal degaussing parameters through the integrated simulation of the diesel engine and degaussing array. The results show that, on a plane at 9 m below the diesel engine, the magnetic flux density at the positive center is the largest, the magnetic field is elliptically distributed, and the calculated value of the magnetic field strength relative to the maximum distortion of the geomagnetic field is as high as 224.35 NT. The error between the measured result and the simulated result is less than 5%, within the allowable error range; the optimal degaussing parameters can be used to reduce the intensity distortion variable of magnetic field on the plane at 9 m below the diesel engine to 8.33 nT, about 95%. Key

Key words: dieselenginemagneticfield, equivalentmagneticchargetheory, finiteelementmethod, demagnetization

中图分类号:

赵建华，应宇辰，郭成豹. 柴油机磁场的计算、试验与消磁优化[J]. 兵工学报, 2020, 41(2): 350-355.

ZHAO Jianhua， YING Yuchen， GUO Chengbao. CalculationTest and Degaussing Optimization of Magnetic Field in Diesel Engine[J]. Acta Armamentarii, 2020, 41(2): 350-355.

参考文献

［1］刘大明. 船舶消磁理论与方法[M].北京:国防工业出版社,2011.
LIU D M. Theory and method of ship demagnetization[M]. Beijing: National Defense Industry Press ,2011.(in Chinese)
[2］ GAO J J, ZHU X L, ZHU W B. Accurate calculating method of marine three-component geomagnetic field in shipboard measurement［C］∥Proceedings of Chinese Automation Congress. Wuhan: Chinese Association of Automation,2015: 1504-1507.
[3］思帆. 保证航行安全的消磁柴油机[J]. 柴油机, 2013,35(6): 66-67.
SI F.Degaussing diesel engine to ensure navigation safety[J]. Diesel Engine,2013,35(6):66-67. (in Chinese)
[4］杜志瀛. 船用柴油机磁性测量及磁性补偿技术研究[J].船舶,1991(4):54-60.
DU Z Y.Research on magnetic measurement and magnetic compensation technology of marine diesel engine[J]. Ship & Boat, 1991(4):54-60. (in Chinese)
[5］姜智鹏,庄飚. 船用柴油机磁场仿真计算及验证[J]. 船舶工程，2005,27(6):68-71.
JIANG Z P,ZHUANG B. Simulation calculation and verification of magnetic field of marine diesel engine[J]. Ship Engineering, 2005,27(6):68-71. (in Chinese)
[6］刘胜道,肖昌汉,周国华，等. 低磁舰艇设备磁场简化建模方法研究[J]. 电工技术学报,2013,28(增刊2):176-179.
LIU S D,XIAO C H,ZHOU G H,et al.Simplified modeling method for ferromagnetic devices in the low magnetic ship[J]. Transactions of China Electrotechnical Society, 2013,28(S2):176-179.(in Chinese)
[7］郭成豹,周炜昶. 舰船消磁绕组磁特征数值计算与验证研究[J]. 兵工学报,2017,38(10):1988-1994.
GUO C B,ZHOU W C.Numerical simulation and verification of magnetic signatures of ship degaussing coils[J]. Acta Armamentarii, 2017,38(10):1988-1994.(in Chinese)
[8］郭成豹，刘大明．舰船磁特征磁矩量法的图形处理单元加速计算研究［J］．兵工学报，2014，35(10): 1638－1643．
GUO C B,LIU D M. GPU-accelerated magnetic moment method for magnetic signatures of ship ［J］. Acta Armamentarii，2014,35(10): 1638-1643.(in Chinese)
[9］ ROBERTS S,BOND A． Predicting the magnetic signature of steel hull ships through FE modeling［C］∥Undersea Defence Technology Exhibition．Liverpool，UK:ACC，2014．

[10］ BIRSAN M,TAN Ｒ. The effect of roll and pitch motion on ship magnetic signature［J］.Journal of Magnetics,2016,21(4):503-508.
[11］朱武兵,庄劲武,赵文春，等. 载体感应磁场的改进积分方程法[J]. 国防科技大学学报,2018,40(3):101-106.
ZHU W B,ZHUANG J W, ZHAO W C, et al. Modified integral equation method for carrier′s induced magnetic field solving[J]. Journal of National University of Defense Technology,2018,40(3): 101-106. (in Chinese)
[12］朱武兵,赵文春,庄劲武，等.非磁性船舶涡流磁场数值建模方法[J].哈尔滨工程大学学报,2019,40(1):112-117.
ZHU W B,ZHAO W C,ZHUANG J W,et al. Modelling method for the eddy-current magnetism of non-magnetic ship[J]. Journal of Harbin Engineering University,2019,40(1):112-117. (in Chinese)
[13］马西奎.电磁场积分方程法、积分微分方程法和边界元法[M].北京：科学出版社，2017.
MA X K.Electromagnetic field integral equation method, integral differential equation method and boundary element method[M]. Beijing: Science Press,2017.(in Chinese)
[14］谢德馨，杨仕友.工程电磁场数值分析与优化设计[M].北京：机械工业出版社，2017.
XIE D X,YANG S Y. Numerical analysis and optimization of engineering electromagnetic fields[M]. Beijing: China Machine Press,2017.(in Chinese)
[15］国防科学技术工业委员会．舰船低磁柴油机规范:GJB 1223—1991（XG1-2015）[S]．北京:中国人民解放军总装备部，2015.
Commission on Science，Technology，and Industry for National Defense. Specifications of low magnetic diesel engines for naval vessels: GJB 1223—1991（XG1-2015）[S]. Beijing: The General Equipment Department of PLA,2015.(in Chinese)

第41卷第2期
2020 年2月兵工学报ACTA
ARMAMENTARIIVol.41No.2Feb.2020

[1]	王雷，李毅，马智慧. 基于Mooney-Rivlin模型的车辆环形橡胶减震器径向刚度计算与参数优化[J]. 兵工学报, 2022, 43(S1): 35-45.
[2]	王锴松，周国华，刘月林，王玉芬，刘胜道. 地磁模拟法测量舰船感应磁场的数值模拟[J]. 兵工学报, 2022, 43(3): 617-625.
[3]	周国华，唐烈峥，孙兆龙，吴轲娜，李志新. 考虑船体涡流影响的舰船消磁线圈电感计算方法[J]. 兵工学报, 2022, 43(11): 2866-2874.
[4]	荣吉利，宋逸博，王玺，郭振，项大林，吴志培. 核爆炸对地冲击作用下土体运动特性等效模拟[J]. 兵工学报, 2021, 42(1): 56-64.
[5]	沈超，周克栋，陆野，乔自平. 内膛损伤枪管对内弹道性能和弹头出膛状态的影响研究[J]. 兵工学报, 2019, 40(4): 718-727.
[6]	沈超，周克栋，陆野，乔自平. 某大口径机枪内膛损伤对弹头挤进过程的影响研究[J]. 兵工学报, 2018, 39(12): 2320-2329.
[7]	郭成豹，周炜昶. 舰船消磁绕组磁特征数值计算与验证研究[J]. 兵工学报, 2017, 38(10): 1988-1994.
[8]	丁传俊, 张相炎. 基于热力耦合有限元模型的弹带挤进过程及内弹道过程的仿真研究[J]. 兵工学报, 2015, 36(12): 2254-2261.
[9]	李淼，钱林方，陈龙淼，徐亚栋. 弹丸卡膛规律影响因素分析[J]. 兵工学报, 2014, 35(8): 1152-1157.
[10]	赵付舟, 王俊席, 崔教林, 汪秀敏. 汽车尾气废热回收的热电模块布置特性研究[J]. 兵工学报, 2013, 34(5): 634-638.
[11]	罗宏浩，廖自力. 基于神经网络的内置式永磁电动机弱磁区最佳电流相位曲线拟合[J]. 兵工学报, 2012, 33(7): 870-874.
[12]	罗宏浩，王福兴. 永磁电动机绕组换接的性能分析与切换电路研究[J]. 兵工学报, 2012, 33(7): 804-809.

柴油机磁场的计算、试验与消磁优化

CalculationTest and Degaussing Optimization of Magnetic Field in Diesel Engine

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 12

编辑推荐

Metrics

本文评价