基于卡尔曼滤波算法的加速度反馈控制在航空光电稳定平台中的应用

doi:10.3969/j.issn.1000-1093.2021.06.016

摘要/Abstract

摘要： 为进一步提高航空光电稳定平台的视轴稳定精度，提出一种基于卡尔曼滤波算法的加速度反馈控制策略。根据光电平台伺服系统模型特点设计卡尔曼滤波器，将卡尔曼滤波器采集的光电平台伺服系统输入输出信号作为自身输入信号，并输出速度的滤波信号和加速度的估计结果。然后将卡尔曼滤波器输出的速度和加速度估计值分别作为被控对象速度环路和加速度环路的反馈信号。进行了模拟仿真和样机实验，结果表明：伺服系统引入加速度反馈控制后，可以使光电平台对2.5 Hz以内不同频率的扰动力矩都具有良好的抑制效果，扰动隔离度优于20 dB；相比于传统单速度环控制方案，阶跃响应的超调量至少降低40%. 由此可见，将加速度环引入传统速度环控制系统可以有效改善光电稳定平台的伺服控制性能，具有较高的工程应用价值。

关键词: 航空光电稳定平台, 加速度反馈, 卡尔曼滤波, 扰动隔离度

Abstract: A method of joining the acceleration feedback control based on Kalman filter in the traditional closed-loop speed control system is proposed to further improve the line-of-sight stabilization accuracy of airborne opto-electronic stabilized platform. Kalman filter collects the input and output signals of the servo system of opto-electronic stabilized platform as its input signal, and outputs the filtered signal of velocity and the estimated result of acceleration. The output speed and acceleration signals are used as the feedback signals of speed loop and acceleration loop, respectively. The simulation and prototype experiment were made. The results show that the acceleration feedback control based on Kalman filter can effectively improve the suppression effect of opto-electronic stabilized platform on the disturbance torque of different frequencies, and the disturbance isolation is better than 20 dB. The step response overshoot is reduced by 40% at least compared to traditional control schemes. The acceleration feedback control based on Kalman filter can effectively improve the servo control performance of opto-electronic stabilized platform.

Key words: airborneopto-electronicstabilizedplatform, accelerationfeedback, Kalmanfilter, disturbanceisolation

中图分类号:

TP273

王正玺，贺柏根，朱小伟. 基于卡尔曼滤波算法的加速度反馈控制在航空光电稳定平台中的应用[J]. 兵工学报, 2021, 42(6): 1257-1264.

WANG Zhengxi, HE Baigen, ZHU Xiaowei. Application of Kalman Filter-based Acceleration Feedback Control in Airborne Opto-electronic Stabilized Platform[J]. Acta Armamentarii, 2021, 42(6): 1257-1264.

参考文献

［1］ HILKERT J M. Inertially stabilized platform technology concepts and principles[J].IEEE Control Systems Magazine,2008,28(1):26-46.
[2］李贤涛,张葆,沈宏海.基于自抗扰控制技术提高航空光电稳定平台的扰动隔离度[J].光学精密工程,2014,22(8):2223-2231.
LI X T,ZHANG B,SHEN H H. Improvement of isolation degree of aerial photoelectrical stabilized platform based on ADRC[J].Optics and Precision Engineering,2014,22(8):2223-2231.(in Chinese)
[3］卢广山,姜长生,耿延洛.高精度机载光电跟踪系统的自适应模糊控制[J].兵工学报,2002,23(4):533-535.
LU G S,JIANG C S,GENG Y L. Adaptive fuzzy control of high accuracy airborne optical-electronic tracking system[J].Acta Armamentarii,2002,23(4):533-535.(in Chinese)
[4］田大鹏,邵晓鹏.航空光学成像与测量技术新进展[J].光学精密工程,2020,28(6):1221-1225.
TIAN D P,SHAO X P. New emerging technologies in airborne optical imaging and measurement[J].Optics and Precision Engineering,2020,28(6):1221-1225. (in Chinese)
[5］丁策,戴明,李嘉全,等.光电陀螺稳定平台的分数阶控制[J].光学精密工程,2014,22(2):383-389.
DING C, DAI M, LI J Q, et al. Fractional control of stabilized platform for photoelectric gyro[J]. Optics and Precision Engineering,2014,22(2):383-389. (in Chinese)
[6］方宇超,李梦雪,车英.基于自抗扰控制的光电平台视轴稳定技术研究[J].红外与激光工程,2018,47(3):225-233.
FANG Y C, LI M X, CHE Y. Study on ADRC based boresight stabilized technology of photoelectric platform[J].Infrared and Laser Engineering,2018,47(3):225-233. (in Chinese)
[7］姬伟，李奇.陀螺稳定平台视轴稳定系统自适应模糊PID控制[J].航空学报,2007,28(1):191-195.
JI W，LI Q. Adaptive fuzzy PID control for LOS stabilization system on gyro stabilized platform[J].Acta Aeronautica et Astronautica Sinica,2007,28(1):191-195. (in Chinese)
[8］ KIAM H A, CHONG G, YUN L. PID control system analysis, design, and technology[J].IEEE Transactions on Control Systems Technology,2005,13(4):559-576.
[9］ STRM K J,HGGLUND T. The future of PID control[J].IFAC Proceedings Volumes,2000,33(4):19-30.
[10］ GRIBANOV P S, LOVLIN S Y,LUKICHEV D V. Realization of acceleration feedback to improve accuracy of servo drive with mechanical elasticity[C]∥Proceedings of IEEE Conference of Russian Young Researchers in Electrical and Electronic Engineering.Moscow,Russia:IEEE,2018：872-877.
[11］ HAN J D, HE Y Q, XU W L. Angular acceleration estimation and feedback control:an experimental investigation[J].Mechatronics,2007,17(9):524-532.
[12］ STUDENNY J, BELANGER P R. Robot manipulator control by acceleration feedback[C]∥Proceedings of IEEE Conference on Decision and Control. Las Vegas, NV,US:IEEE,2007：1070-1072.
[13］徐国柱,刘樾,孟凡军.利用加速度反馈改善转台低速性能[J].中国惯性技术学报,2008,16(4):502-504.
XU G Z,LIU Y,MENG F J. Improving low-rate performance of turntable by acceleration feedback[J].Journal of Chinese Inertial Technology,2008,16(4):502-504.(in Chinese)
[14］邱志成,李城.基于加速度反馈的两杆柔性机械臂振动控制与实验研究[J].空间控制技术与应用,2018, 44(5):1-6，13.
QIU Z C,LI C. Experimental research of vibration control on two-link flexible manipulator based on acceleration feedback[J].Aerospace Control and Application,2018, 44(5):1-6，13.(in Chinese)
[15］孔德杰,戴明,程志峰,等.动基座光电稳定平台伺服系统中加速度反馈的实现[J].光学精密工程,2012,20(8):1782-1788.
KONG D J,DAI M,CHENG Z F, et al. Realization of acceleration feedback for servo system of moving base optoelectronic platform[J].Optics and Precision Engineering,2012,20(8):1782-1788.(in Chinese)
[16］李鹏飞,汪光森,张向明,等.基于光电编码器的角加速度观测器设计[J].计算技术与自动化,2017,36(2):78-84.
LI P F,WANG G S,ZHANG X M, et al. Design of angular acceleration observer based on photoelectric encode[J].Computing Technology and Automation,2017,36(2):78-84.(in Chinese)
[17］田竞,邓超,曹政,等.加速度反馈技术在惯性稳定平台中的应用[J].光电工程,2016,43(12):40-45.
TIAN J,DENG C,CAO Z, et al. Application of acceleration feedback techniques on inertial stabilization platform[J].Opto-Electronic Engineering,2016,43(12):40-45.(in Chinese)
[18］王正玺.机载光电侦察平台高精度视轴稳定及像移补偿控制技术研究[D].长春：中国科学院长春光学精密机械与物理研究所，2019.
WANG Z X. High precision los stabilization and image shift compensation control technology for aeronautical photoelectric stabilization platform[D].Changchun:Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Sciences,2019. (in Chinese)
[19］ BELANGER P R, DOBROVOLNY P, HELMY A, et al. Estimation of angular velocity and acceleration from shaft-encoder measurements[J].International Journal of Robotics Research,1998,17(11):1225-1233.

[1]	梅程，彭建鑫，胡宇辉. 单轴并联混合动力商用车整车总质量在线估计算法[J]. 兵工学报, 2021, 42(9): 1838-1846.
[2]	陈林秀，郝明瑞，赵佳佳. 混合噪声条件下的目标被动定位算法[J]. 兵工学报, 2021, 42(9): 1923-1930.
[3]	卢雨，衣晓. 基于动态规划和双变量容积卡尔曼滤波的空基外辐射源定位算法[J]. 兵工学报, 2021, 42(4): 808-816.
[4]	张羽，王朋，刘纪元，钟荣兴，韦琳哲，迟骋. 合成孔径声纳重叠相位中心与惯性导航系统联合估计运动误差算法[J]. 兵工学报, 2021, 42(3): 588-597.
[5]	王振峰，李飞，王新宇，杨建森，秦也辰. 基于交互式多模型无迹卡尔曼滤波的悬架系统状态估计[J]. 兵工学报, 2021, 42(2): 242-253.
[6]	王宁，李银伢，戚国庆，盛安冬. 不完全量测下基于信息一致性的分布式容积卡尔曼滤波算法[J]. 兵工学报, 2021, 42(11): 2396-2408.
[7]	张征, 刘春光, 马晓军, 张运银. 一种基于数据融合的全轮驱动车辆质心侧偏角估计方法[J]. 兵工学报, 2020, 41(5): 842-849.
[8]	孙欢，杨宾峰，管桦，王润. 基于联合估计迭代算法的三轴磁力仪标定补偿方法[J]. 兵工学报, 2020, 41(5): 902-910.
[9]	张伽伟，喻鹏，姜润翔, 孙宝全. 基于舰船电场的目标跟踪方法研究[J]. 兵工学报, 2020, 41(3): 559-566.
[10]	张博伦，周荻. 引入角加速度测量的柔性飞行器姿态控制方法[J]. 兵工学报, 2020, 41(11): 2225-2233.
[11]	张梦得, 李开龙, 胡柏青, 吕旭. 辅助信息源短时失效下的捷联惯性基组合导航算法[J]. 兵工学报, 2020, 41(10): 2008-2015.
[12]	彭博，岑梦希. 速度匹配加机动辅助的滚转弹滚转角空中对准法[J]. 兵工学报, 2019, 40(7): 1390-1400.
[13]	颜冰，孙宝全，张伽伟. 基于滤波器组的船舶静电场跟踪[J]. 兵工学报, 2019, 40(7): 1468-1475.
[14]	张成举，王聪，曹伟，王金强. 基于无迹卡尔曼滤波的超空泡航行体最优控制研究[J]. 兵工学报, 2019, 40(6): 1235-1243.
[15]	余潇，柯芳，袁佳，高歆杨. 基于迭代无偏有限冲击响应滤波的共轴跟踪技术研究[J]. 兵工学报, 2019, 40(5): 1020-1029.