强冲击载荷下电磁缓冲器有限元仿真模型

doi:10.3969/j.issn.1000-1093.2021.05.003

兵工学报 ›› 2021, Vol. 42 ›› Issue (5): 913-923.doi: 10.3969/j.issn.1000-1093.2021.05.003

强冲击载荷下电磁缓冲器有限元仿真模型

李子轩^1，2，杨国来¹，刘宁¹

（1.南京理工大学机械工程学院，江苏南京 210094； 2.山东理工大学机械工程学院，山东淄博 255049）

上线日期:2021-06-12
通讯作者: 杨国来(1968—)，男，教授，博士生导师 E-mail:yyanggl@njust.edu.cn
作者简介:李子轩(1991—)，男，博士研究生。E-mail：lizixuan@njust.edu.cn
基金资助:
国家自然科学基金项目(11572158)

Finite Element Simulation Model for Electromagnetic Buffer under Intensive Impact Load

LI Zixuan^1,2， YANG Guolai¹， LIU Ning¹

(1.School of Mechanical Engineering, Nanjing University of Science and Technology, Nanjing 210094, Jiangsu, China；2.School of Mechanical Engineering, Shandong University of Technology, Zibo 255049, Shandong, China)

Online:2021-06-12

摘要/Abstract

摘要： 为获得强冲击载荷下电磁缓冲器的电磁与阻尼特性，针对其速度高、加速度大的运动特点，提出了一种改进的指数去磁模型来模拟钕铁硼永磁材料的去磁过程，同时采用一种改进的矢量磁滞模型来考虑软磁材料的磁滞效应。在此基础上，建立考虑去磁效应与磁滞效应的初级-次级涡流耦合时步有限元模型。采用冲击载荷模拟实验，验证了有限元模型的准确性；结合磁场测试得到并分析了冲击电磁缓冲过程的电磁与阻尼规律；通过开展强冲击载荷实验得到了电磁缓冲器高速运动条件下的阻尼规律。研究结果表明：数值分析方法具有高可靠性；去磁效应随缓冲速度增大而增强；阻尼系数随着缓冲速度的增大而减小；磁滞作用能扰乱磁场分布，影响阻尼力变化规律。

关键词: 电磁缓冲器, 强冲击载荷, 指数去磁模型, 矢量磁滞

Abstract: In order to obtain the electromagnetic and damping characteristics of the electromagnetic buffer under intensive impact load, an improved exponential demagnetization model is proposed to simulate the demagnetization process of NdFeB permanent magnets. An improved vector hysteresis model is adopted to consider the hysteresis effect of soft magnetic materials. And a primary-secondary eddy current coupled time-step finite element model is established, in which demagnetization and hysteresis are considered. The accuracy of the finite element model is verified through the laboratory impact load test. The damping and electromagnetic characteristics were obtained and analyzed through the magnetic field test. The intensive impact test was carried out to obtain the damping characteristics of electromagnetic buffer under high buffering velocity conditions. The results show that the finite element model has high reliability. The demagnetization effect increases with the increase in buffering velocity, which leads to the decreased damping coefficient. Hysteresis effect can disturb the magnetic field distribution and affect the damping force.

Key words: electromagneticbuffer, intensiveimpactload, exponentialdemagnetizationmodel, vectormagnetichysteresis

中图分类号:

TJ303⁺.4

李子轩，杨国来，刘宁. 强冲击载荷下电磁缓冲器有限元仿真模型[J]. 兵工学报, 2021, 42(5): 913-923.

LI Zixuan， YANG Guolai， LIU Ning. Finite Element Simulation Model for Electromagnetic Buffer under Intensive Impact Load[J]. Acta Armamentarii, 2021, 42(5): 913-923.

参考文献［1］

［1］

KANG G H, HUR J, SUNG H G, et al. Optimal design of spoke type BLDC motor considering irreversible demagnetization of permanent magnet[C]∥Proceedings of the Sixth International Conference on Electrical Machines and Systems. Beijing, China: IEEE, 2003.[2］ KANG G H, HUR J, NAM H, et al. Analysis of irreversible magnet demagnetization in line-start motors based on the finite-element method[J]. IEEE Transactions on Magnetics, 2003, 39(3): 1488-1491.[3］ KIM K C, LIM S B, KOO D H, et al. The shape design of permanent magnet for permanent magnet synchronous motor considering partial demagnetization [J]. IEEE Transactions on Magnetics, 2006, 42(10): 3485-3487.[4］ FAROOQ J, SRAIRI S, DJERDIR A, et al. Use of permeance network method in the demagnetization phenomenon modeling in a permanent magnet motor [J]. IEEE Transactions on Magnetics, 2006, 42(4): 1295-1298.[5］ RUOHO S, DLALA E, ARKKIO A. Comparison of demagnetization models for finite-element analysis of permanent-magnet synchronous machines [J]. IEEE Transactions on Magnetics, 2007, 43(11): 3964-3968.[6］ KOU B Q, JIN Y X, ZHANG L, et al. Characteristic analysis and control of a hybrid excitation linear eddy current brake [J]. Energies, 2015, 8(7): 7441-7464.[7］ XIAO D H, ZHOU X H, GAO Y, et al. Application of eddy current damping effect to design a novel magnetic damper[C]∥Proceedings of the 2015 2nd International Forum on Electrical Engineering and Automation. Guangzhou, China: Atlantis Press, 2016: 335-339.[8］ YAZDANPANAH R. Design and analysis of radial-flux hybrid excitation eddy current brake[C]∥Proceedings of the 2019 10th International Power Electronics, Drive Systems and Technologies Conference (PEDSTC). Shiraz, Iran: IEEE, 2019.[9］ KOU B Q, ZHANG H, YIN X R, et al. Research on long stroke moving secondary permanent magnet linear eddy current brake [J]. CES Transactions on Electrical Machines and Systems, 2019, 3(1): 19-29.[10］ CHEAH S K, SODANO H A. Novel eddy current damping mechanism for passive magnetic bearings [J]. Journal of Vibration and Control, 2008, 14(11): 1749-1766.[11］蒲晓晖, 徐俊, 李士盈, 等. 电磁阻尼器惯性质量对汽车馈能悬架减振性能的影响[J]. 西安交通大学学报, 2019, 53(6): 62-68,84.PU X H, XU J, LI S Y, et al. Effects of inertial mass of electromagnetic damper on vibration insulation performance of vehicle regenerative suspension[J]. Journal of Xi'an Jiaotong University, 2019, 53(6): 62-68,84.(in Chinese)[12］寇宝泉, 金银锡, 张赫, 等. 新型串联磁路混合励磁直线涡流制动器特性分析[J]. 电工技术学报, 2016, 31(15): 62-72.KOU B Q, JIN Y X, ZHANG H, et al. Characteristic analysis of a novel linear eddy current brake with serial magnetic circuit and hybrid excitation[J]. Transactions of China Electrotechnical Society, 2016, 31(15): 62-72. (in Chinese)[13］赵吉文, 何中燕, 董菲, 等. 基于电磁阻尼-弹簧系统的永磁同步直线电机推力波动抑制研究[J]. 中国电机工程学报, 2019, 39(17): 5237-5246,5304.ZHAO J W, HE Z Y, DONG F, et al. Thrust fluctuation suppression of permanent magnet synchronous linear motor by using electromagnetic damping-spring system[J]. Proceedings of the CSEE, 2019, 39(17): 5237-5246,5304. (in Chinese)[14］ CHEN F, ZHAO H, DING H. Eddy current damper design for vibration suppression in robotic milling process[C]∥Proceedings of the 2018 IEEE International Conference on Robotics and Automation. Brisbane, QLD, Australia: IEEE, 2018.[15］ YAN B, MA H Y, YU N, et al. Theoretical modeling and experimental analysis of nonlinear electromagnetic shunt damping [J]. Journal of Sound and Vibration, 2020, 471: 115184.[16］ LIN D S, ZHOU P, LU C, et al. Construction of magnetic hysteresis loops and its applications in parameter identification for hysteresis models[C]∥Proceedings of the 2014 International Conference on Electrical Machines. Berlin, Germany: IEEE, 2014.[17］ LIN D S, ZHOU P, BERGQVIST A. Improved vector play model and parameter identification for magnetic hysteresis materials [J]. IEEE Transactions on Magnetics, 2014, 50(2): 357-360.[18］高树滋, 陈运生, 张月林, 等. 火炮反后坐装置设计[M]. 北京: 兵器工业出版社, 1995.GAO S Z, CHEN Y S, ZHANG Y L, et al. Design of gun recoil mechanism[M]. Beijing: Publishing House of Ordnance Industry, 1995. (in Chinese)

强冲击载荷下电磁缓冲器有限元仿真模型

Finite Element Simulation Model for Electromagnetic Buffer under Intensive Impact Load

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献［1］

相关文章 1

编辑推荐

Metrics

本文评价

强冲击载荷下电磁缓冲器有限元仿真模型

Finite Element Simulation Model for Electromagnetic Buffer under Intensive Impact Load

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献 ［1］

相关文章 1

编辑推荐

Metrics

本文评价

参考文献［1］