多次模拟弹射载荷作用下水泥混凝土路面动态响应

doi:10.12382/bgxb.2021.0380

摘要/Abstract

摘要： 道路结构作为承载基础，与发射装备构成了动力耦合系统，冲击载荷作用下路面的响应特性将直接影响到导弹发射安全性。为研究多次弹射载荷下水泥混凝土道路结构的动态响应，以压缩空气为动力源搭建模拟弹射载荷生成装置，在三维试槽中铺筑水泥混凝土路面，面层中铺设应变传感器，土基中埋设土压力传感器，通过多次冲击加载试验获取模拟弹射载荷作用下土基压应力和面层应变变化规律，分析土基内压应力与深度及载荷作用面中心点距离间的关系，得到多次模拟弹射载荷下面层破坏形式及破坏机理。研究结果表明：冲击压力与土基峰值压应力呈线性关系；距离载荷中心点3 300 mm处，不同模拟弹射载荷下各深度处的土基压应力峰值已经非常小，模拟弹射载荷的径向影响范围为3 300 mm以内；模拟弹射载荷较小时面层为弹性变形，模拟弹射载荷增加到0.77 MPa时混凝土面层产生辐射状贯穿裂缝；弹射载荷作用下路面出现整体沉降。

关键词: 水泥混凝土路面, 弹射载荷, 多次冲击响应, 土基压应力, 面层破坏

Abstract: As the road structure is coupled dynamically with the launching system, the impact mechanical behaviors of pavements will directly affect missile launching safety. A loading device for simulating cold launching loads is developed with compressed air as a power source. Then, an asphalt concrete pavement is paved in a three-dimensional test slot fitted with strain and soil pressure sensors. The variation laws of surface layer displacement is obtained by analyzing the response of the pavement under multiple impact loads, and the relationship between the internal pressure stress of the soil subgrade and the depth and distance from the load center is studied. The failure modes and mechanisms of the surface layer under multiple simulated cold launching loads are observed. The experimental results show a linear relationship between the impact pressure and the peak compressive stress of the soil subgrade. The peak compressive stress of the soil subgrade at different depths under different impact loads is very small at 3 300 mm away from the center of load. The surface layer is elastically deformed when the impact load is small, and radial penetrating cracks are generated on the concrete surface layer when the impact load is increased to 0.77 MPa. The cold launching load cause an integral settlement in the pavement.

Key words: cementconcretepavement, coldlaunchingload, multi-impactresponse, soilsubgradestress, surfacelayerfailure

中图分类号:

TJ768.1

张震东，高原，马大为，朱忠领，王玺. 多次模拟弹射载荷作用下水泥混凝土路面动态响应[J]. 兵工学报, 2022, 43(7): 1706-1717.

ZHANG Zhendong， GAO Yuan， MA Dawei， ZHU Zhongling， WANG Xi. Simulation of the Dynamic Response of Cement Concrete Pavement under Multiple Cold Launch Loads[J]. Acta Armamentarii, 2022, 43(7): 1706-1717.

参考文献

［1］ PICOUX B，EL AYADI A，PETIT C. Dynamic response of a flexible pavement submitted by impulsive loading［J］.Soil Dynamics and Earthquake Engineering，2009，29(5):845-854.
［2］杨永顺，王林，韦金城，等.重载作用下典型路面结构动态响应数据采集与分析［J］.公路交通科技，2010，27(5):11-16.
YANG Y S，WANG L，WEI J C，et al.Typical pavement structure dynamic response data collection and analysis under heavy vehicle loading［J］.Journal of Highway and Transportation Research and Development，2010，27(5):11-16.(in Chinese)
［3］周玉民，谈至明，田波.车-路耦合作用力特性及混凝土路面动态响应［J］.同济大学学报(自然科学版)，2012，40(6):854-860.
ZHOU Y M，TAN Z M，TIAN B.Vehicle-road coupling force characteristics and dynamic response of concrete pavements［J］.Journal of Tongji University(Natural Science)，2012，40(6):854- 860.(in Chinese)
［4］陈恩利，刘永强，赵进宝.移动荷载作用下路面动力响应响应试验研究［J］.振动与冲击，2014，33(16):62-67.
CHEN E L，LIU Y Q，ZHAO J B. Experiments on dynamic response of pavement under moving load［J］.Journal of Vibration and Shock，2014，33(16):62-67.(in Chinese)
［5］ WU J T，YE F，FREDERICK H，et al. Strain response of a semi-rigid base asphalt pavement based on heavy-load full-scale accelerated pavement testing with fibre Bragg grating sensors［J］.Road Materials and Pavement Design，2015，16(2):316-333.
［6］刘大维，戴宗宏，陈洋，等.车辆多轮动载作用下柔性路面动应力响应［J］.中国公路学报，2017，30(11):36-42.
LIU D W，DAI Z H，CHEN Y，et al. Dynamic stress response of flexible pavement under multiple wheel dynamic loads of vehicle［J］.China Journal of Highway and Transport，2017，30(11):36-42.(in Chinese)
［7］唐学军，苏卫国.路基刚度对冲击压实旧混凝土路面力学行为的影响分析［J］.土木工程学报，2006，39(4):121-126.
TANG X J，SU W G.Influence of subgrade modulus on the mechanical behaviors of existing impact-compacted concrete pavement［J］.China Civil Engineering Journal，2006，39(4):121- 126. (in Chinese)
［8］胡昌斌，陈友杰.多遍冲击碾压动荷载作用下路面板力学响应分析［J］.工程力学，2009，26(12):189-195.
HU C B，CHEN Y J.Mechanical response of cement concrete pavement under impact roller compact load at different times［J］.Engineering Mechanics，2009，26(12): 189-195.(in Chinese)
［9］胡昌斌，阙云.多遍冲击碾压混凝土路面时路基的动力响应分析［J］.岩土力学，2009，30(8):2517-2522.
HU C B，QUE Y.Dynamic response of subgrade under impact compacted load with multiple times［J］.Rock and Soil Mechanics，2009，30(8):2517-2522.(in Chinese)
［10］胡昌斌，袁燕.冲击碾压改建路面施工对路基动力作用的试验研究［J］.岩土力学，2011，32(3):745-752.
HU C B，YUAN Y.Dynamic soil pressure characteristics of embankment under impact rolling load during rehabilitation of PCCP［J］.Rock and Soil Mechanics，2011，32(3):745-752.(in Chinese)
［11］王林峰，唐红梅，陈洪凯.落石冲击作用下公路破坏机理研究［J］.人民长江，2012，43(5): 64-67.
WANG L F，TANG H M，CHEN H K.Study on damage mechanism of pavement slab under rockfall condition［J］.Yangtze River，2012，43(5):64-67.(in Chinese)
［12］张东亮，黄达.落石冲击旁山填方路基边坡破坏数值模拟［J］.地下空间与工程学报，2017，13(增刊1):135-142.
ZHANG D L，HUANG D.Numerical modeling of failure of fill roadbed slope beside hill slope induced by rock-fall impact［J］.Chinese Journal of Underground Space and Engineering，2017，13(S1): 135-142.(in Chinese)
［13］ MODARRES A，SHABANI H.Nvestigating the effect of aircraft impact loading on the longitudinal top-down crack propagation parameters in asphalt runway pavement using fracture mechanics［J］.Engineering Fracture Mechanics，2015，150:28-46.
［14］ TAN Y Q，FU Y K，LI Y L，et al.Responses of snow-melting airfield rigid pavement under aircraft loads and temperature loads and their coupling effects［J］. Transportation Geotechnics，2018，14:107-116.
［15］ ALI S，FAWZIA S，THAMBIRATNAM D，et al. Performance of protective concrete runway pavement under aircraft impact loading［J］.Structure and Infrastructure Engineering，2020，16(12):1698-1710.
［16］周晓和，马大为，仲健林，等.强冲击载荷下钢筋混凝土路面动态响应影响因素敏感度分析［J］.机械制造与自动化，2014，43(5):74-76，83.
ZHOU X H，MA D W，ZHONG J L，et al.Sensitivity analysis of dynamic response influencing factor of reinforced concrete pavement under heavy impact loading［J］.Machine Building and Automation，2014，43(5):74-76，83. (in Chinese)
［17］张震东，马大为，胡建国，等.弹射冲击载荷作用下沥青混凝土路面面层的损伤［J］.工程力学，2015，32(10):161-168.
ZHANG Z D，MA D W，HU J G，et al.Damage of surface layer of asphalt concrete pavement under launching impact load［J］.Engineering Mechanics，2015，32(10):161-168.(in Chinese)
［18］ DING F，YIN Y，CAI L C，et al.Mechanical response of typical cement concrete pavements under impact loading［J］. Mathematical Problems in Engineering，2017(6): 2050285.
［19］冯锦艳，郭志培，于志全. 冲击载荷下低等级沥青路沉降计算方法探讨［J］.地下空间与工程学报，2016，12(增刊2)：889- 893.
FENG J Y，GUO Z P，YU Z Q. Discussion on settlement calculation methods of the low level asphalt pavement under action of impact load［J］.Chinese Journal of Underground Space and Engineering，2016，12(S2):889-893.(in Chinese)
［20］林钦栋，冯春，唐德泓，等.冲击载荷作用下路面结构的沉降及破坏特征［J］.爆炸与冲击，2019，39(11): 106-119.
LIN Q D，FENG C，TANG D H，et al.The settlement and damage characteristics of pavement structure under impulse load［J］.Explosion and Shock Waves，2019，39(11): 106-119.(in Chinese)
［21］ ZHANG Q L，ZHI Z H，FENG C，et al.Investigation of concrete pavement cracking under multi-head impact loading via the continuum-discontinuum element method［J］.International Journal of Impact Engineering，2020，135:103410.
［22］张震东，马大为，仲健林，等.某型导弹冷发射装备场坪适应性研究［J］.兵工学报，2020，41(2):280-290.
ZHANG Z D，MA D W，ZHONG J L，et al. Research on adaptability of a cold launching system of missile to launching site［J］.Acta Armamentarii，2020，41(2):280-290. (in Chinese)