Failure Modes of Ring-stiffened Convex Cone-cylinder in Deep Underwater Explosion

doi:10.3969/j.issn.1000-1093.2021.05.011

Abstract

Abstract: The dynamic response of submarine structure at underwater explosion (UNDEX), which is significantly affected by the depth of water, is the basis of submarine safety design. Based on the protection of typical submarine structure in deep underwater explosion (D-UNDEX), the failure modes of the ring-stiffened convex cone-cylinder in D-UNDEX are studied. The D-UNDEX experiment with the maximum water depth of 500m was completed. The dynamic response process of convex cone-cylinder under various conditions was obtained by ABAQUS numerical simulation method. Based on the deformation and failure degree of the structure, three failure modes of ring-stiffened convex cone-cylinder were obtained, and the evolution and transformation processes of different failure modes were revealed. The results show that, with the increase in water depth and shock factor, the deformation and failure results of ring-stiffened convex cone-cylinder are more serious, and the evolution and transformation processes of failure mode are more complex.

Key words: ring-stiffenedconvexcone-cylinder, deepunderwaterexplosion, failuremode, submarinestructure

CLC Number:

O383

LIANG Haozhe, ZHANG Qingming, LONG Renrong, REN Siyuan. Failure Modes of Ring-stiffened Convex Cone-cylinder in Deep Underwater Explosion[J]. Acta Armamentarii, 2021, 42(5): 987-996.

References

［1］朱锡,吴梵.舰艇强度［M］.北京:国防工业出版社,2005.
ZHU X, WU F. Ship strength［M］. Beijing: National Defense Industry Press, 2005. (in Chinese)
［2］ BRETT J M, YIANNAKOPOLOUS G. A study of explosive effects in close proximity to a submerged cylinder［J］. International Journal of Impact Engineering, 2008, 35(4): 206-225.
［3］袁建红,朱锡,张振华.水下爆炸载荷作用下加筋圆柱壳结构弹塑性动力响应研究［J］.振动与冲击,2012,31(24):131-136.
YUAN J H, ZHU X, ZHANG Z H. Elastic-plastic dynamic response of a stiffened cylindrical shell subjected to underwater explosion shock wave［J］. Journal of Vibration and Shock, 2012, 31(24): 131-136. (in Chinese)
［4］卢熹,王树山,马峰,等.水下爆炸环肋圆筒损伤特性实验及数值模［J］.北京理工大学学报,2015, 35(10): 995-1000.
LU X, WANG S S, MA FENG, et al. Experimental an numerical study of damage characteristics for ring-stiffened cylinder subjected to underwater explosion［J］. Transactions of Beijing Institute of Technology,2015,35(10): 995-1000. (in Chinese)
［5］ GAUCH E, LEBLANC J, SHUKLA A. Near field underwater explosion response of polyurea coated composite cylinders［J］. Composite Structures,2018, 202:836-852.
［6］汪俊,刘建湖,李玉节.加筋圆柱壳水下爆炸动响应数值模拟［J］.船舶力学,2006,10(2):126-137.
WANG J, LIU J H, LI Y J. Numerical simulation of dynamic response of ring-stiffened cylindrical shell subjected to underwater explosion［J］. Journal of Ship Mechanics, 2006,10(2):126-137. (in Chinese)
［7］姚熊亮,张阿漫,许维军,等.基于ABAQUS软件的舰船水下爆炸研究［J］.哈尔滨工程大学学报, 2006,27(1):37-41.
YAO X L, ZHANG A M, XU W J, et al. Research on warship underwater explosion with ABAQUS software［J］. Journal of Harbin Engineering University, 2006, 27(1):37-41. (in Chinese)
［8］贾宪振.基于通用程序的水下爆炸及其对结构作用的数值模拟研究［D］.南京：南京理工大学.2007.
JIA X Z. Numerical simulation of underwater explosion and its effect on structures based on commercial softwares［D］. Nanjing: Nanjing University of Science and Technology， 2007. (in Chinese)
［9］ FATHALLAH E, QI H, TONG L L, et al. Numerical investigation of the dynamic response of optimized composite elliptical submersible pressure hull subjected to non-contact underwater explosion［J］. Composite Structures, 2015, 121:121-133.
［10］ GANNON L. Submerged aluminum cylinder response to close-proximity underwater explosions - a comparison of experiment and simulation［J］. International Journal of Impact Engineering,2019,133: 103339.
［11］ NAGAI T. On the results of damages of cylindrical shells due to underwater explosion［J］. Journal of Zosen Kiokai, 1965, 17:184-194.
［12］余小菲.加筋圆柱壳在水下爆炸载荷作用下的动力响应及动力屈曲［D］.武汉：华中科技大学,2007.
YU X F. Dynamic response and buckling of stiffened cylindrical shells subjected to underwater explosion loadings［D］. Wuhan: Huazhong University of Science and Technology,2007. (in Chinese)
［13］汪俊.加筋圆柱壳在静压和水下爆炸联合作用下的动态损伤分析方法研究［D］.无锡:中国船舶科学研究中心,2015.
WANG J. Investigation on analysis method for dynamic damage of stiffened cylindrical shell under static subjected to UNDEX loading［D］. Wuxi: China Ship Scientific Research Center, 2015. (in Chinese)
［14］谢作水,王自力,吴剑国.潜艇结构分析［M］.武汉:华中科技大学出版社,2004.
XIE Z S, WANG Z L, WU J G. Submarine structure analysis［M］. Wuhan. Huangzhong University of Science and Technology Press, 2004.(in Chinese)
［15］郭日修,吕岩松,黄加强,等.加肋锥环柱结合壳试验研究［J］.船舶力学, 2008,12(2):252-257.
GUO R X, L Y S, HUANG J Q, et al. Experimental research on the ring-stiffened cone-toroid-cylinder combination shell［J］. Journal of Ship Mechanics,2008,12(2):252-257. (in Chinese)
［16］郭日修,吕岩松.凹型加肋锥-环-柱结合壳局部加强方式的研究［J］.哈尔滨工程大学学报,2010,31(2):170-176.
GUO R X, LU Y S. Research on local strengthening modes for ring-stiffened concave cone-toroid-cylinder combination shells［J］. Journal of Harbin Engineering University,2010,31(2):170- 176. (in Chinese)
［17］ COLE R H. Underwater explosion［M］. Princeton, NJ, US：Princeton University Press, 1948.
［18］梁浩哲.深水爆炸对典型深潜结构的破坏效应［D］.北京：北京理工大学,2020.
LIANG H Z. Damage effect of deep-underwater-explosion on typical submarine structure［D］.Beijing: Beijing Institute of Technology,2020.(in Chinese)
［19］李德聪,郑绍文,吴国民.关于水下中远场爆炸相似律与冲击因子的讨论［J］.兵工学报, 2015,36(增刊1):46-52.
LI D C, ZHENG S W, WU G M. Discussion on underwater mid-and far-field explosion similarity laws and impulsive factor［J］. Acta Armamentarii， 2015，36(S1):46-52. (in Chinese)

[1]	ZHANG Zhendong, WANG Xueqin, REN Jie, LIU Zheng, GAO Yuan, WANG Xi. Quasi-static Compression Responseof Multicellular Structures with Carbon Fiber Reinforced Epoxy Composite Tubes [J]. Acta Armamentarii, 2022, 43(5): 1185-1193.
[2]	XU Wei, HOU Hai-liang, ZHU Xi, CHEN Chang-hai, LI Mao. Investigation on the Damage Mechanism of Blunt Projectile against Thin Plate [J]. Acta Armamentarii, 2018, 39(5): 883-892.
[3]	LI Dian， HOU Hai-liang， DAI Wen-xi, ZHU Xi， LI Mao， CHEN Chang-hai. Experimental Investigation on Damage of Glassfiber Sandwich Structure under Explosion and Fragment Loadings [J]. Acta Armamentarii, 2017, 38(5): 877-885.
[4]	DING Li, JIANG Jian-wei, MEN Jian-bing, WANG Shu-you. Numerical Simulation and Mechanism Analysis of EFP’s Fracture in Forming Process [J]. Acta Armamentarii, 2017, 38(3): 417-423.