水下连发射弹的超空泡流动特性研究

doi:10.3969/j.issn.1000-1093.2018.11.017

兵工学报 ›› 2018, Vol. 39 ›› Issue (11): 2228-2235.doi: 10.3969/j.issn.1000-1093.2018.11.017

水下连发射弹的超空泡流动特性研究

施红辉¹，周东辉¹，孙亚亚¹，贾会霞¹，侯健²

（1.浙江理工大学机械与自动控制学院，浙江杭州 310018； 2.海军工程大学兵器工程学院，湖北武汉 430033）

收稿日期:2018-02-01 修回日期:2018-02-01 上线日期:2018-12-25
作者简介:施红辉（1962—），男，教授，博士生导师。E-mail：hhshi@zstu.edu.cn
基金资助:
浙江省自然科学基金项目（LY16A020003）

Research on the Characteristics of Supercavitating Flows Caused by Underwater Continuously Fired Projectiles

SHI Hong-hui¹, ZHOU Dong-hui¹, SUN Ya-ya¹, JIA Hui-xia¹, HOU Jian²

(1.College of Mechanical Engineering and Automation, Zhejiang Sci-Tech University, Hangzhou 310018, Zhejiang, China; 2.College of Weaponry Engineering, Naval University of Engineering, Wuhan 430033, Hubei, China)

Received:2018-02-01 Revised:2018-02-01 Online:2018-12-25

摘要/Abstract

摘要： 基于Fluent流体仿真软件，采用用户自定义函数控制的动网格技术，对水下连发射弹的超空泡流场进行了数值模拟。通过与1组实验工况的比较，证实了所采用的数值模拟计算方法的可靠性。分析了两连发和3连发射弹情况下，超空泡流场的相互作用及其变化机理；得出了射弹超空泡无量纲长度在超空泡流场作用下的变化特点，计算出了流场的速度变化曲线和速度矢量等。研究结果表明：两射弹间的超空泡融合后，会在超空泡尾部区产生高速回射流并产生大量旋涡。这些旋涡引起的扰动能致使后续超空泡快速溃灭，表明了超空泡的极其不稳定性。后面的射弹进入前面射弹的空泡内后，其阻力系数达到最小值。当两连发超空泡射弹通过扰动区域时，前后超空泡都受到干扰，从而造成了它们的阻力系数增减。

关键词: 超空泡, 水下连发射弹, 动网格技术, 回射流, 阻力系数

Abstract: Based on the FLUENT software and the dynamic grid technology controlled by user-defined function, the supercavitation flows of the continuously fired projectiles were numerically studied to analyze the characteristics of supercavitating flows. The numerical results of the supercavity shape and the drag coefficient of projectiles are effectively consistent with the experimental results, which indicates that the numerical simulation is exact, and the drag coefficient of projectile presents an increasing trend with the decrease in velocity of projectile. The mechanisms of supercavitations of two and three continuously fired projectiles are studied. The change rule of non-dimensional length is concluded, and the variation curve of velocity in flow field and the velocity vector are analyzed. The results show that, after the supercavity fusion of two projectiles, a high velocity re-entrant jet and many vortices are found in the aft of supercavitation. The vortices can lead to the rapid collapse of projectile supercavitation, which also indicates the extreme instability of supercavitation. The drag coefficient of two projectiles can reach to the minimum value when the two projectiles enter in a supercavitation. When the supercavitations of two continuously fired projectiles pass through the disturbance field, the supercavitations are disturbed, thus resulting in the increase and decrease in their drag coefficients. Key

Key words: supercavitation, underwatercontinuouslyfiredprojectile, dynamicgridtechnology, re-entrantjet, dragcoefficient

中图分类号:

施红辉，周东辉，孙亚亚，贾会霞，侯健. 水下连发射弹的超空泡流动特性研究[J]. 兵工学报, 2018, 39(11): 2228-2235.

SHI Hong-hui, ZHOU Dong-hui, SUN Ya-ya, JIA Hui-xia, HOU Jian. Research on the Characteristics of Supercavitating Flows Caused by Underwater Continuously Fired Projectiles[J]. Acta Armamentarii, 2018, 39(11): 2228-2235.

参考文献

［1］ Hrubes J D.High-speed imaging of supercavitating underwater projectiles[J]. Experiments in Fluids, 2001, 30(1):57-64.
［2］ Jafarian A, Pishevar A. Numerical simulation of steady supercavitating flows[J]. Journal of Applied Fluid Mechanics, 2016, 9(6): 2981-2992.
［3］徐清沐, 薛雷平. 带凹槽和带凸起的圆盘空化器超空泡流数值研究[J]. 水动力学研究与进展:A 辑, 2013, 28(5): 518-525.
XU Qing-mu, XUE Lei-ping.Numerical study of supercavity flow of disk cavitator with grooves or convexes [J].Chinese Journal of Hydrodynamics, 2013, 28(5): 518-525. (in Chinese)
［4］冯光, 颜开. 超空泡航行体水下弹道的数值计算[J]. 船舶力学, 2005, 9(2): 1-8.
FENG Guang, YAN Kai. Numerical calculation of underwater tra-jectory of supercavitating bodies[J]. Journal of Ship Mechanics, 2005,9 (2): 1-8. (in Chinese)
[5］栗夫园, 张宇文, 党建军, 等. 锥形空化器流体动力特性研究[J]. 兵工学报, 2014, 35(7): 1040-1044.
LI Fu-yuan, ZHANG Yu-wen, DANG Jian-jun, el at.Research on hydrodynamic characteristics of conical cavitator[J]. Acta Armamentarii, 2014,35(7):1040-1044. (in Chinese)
[6］施红辉, 孙亚亚, 周杨洁, 等. 水下航行体表面凹槽数对超空泡流场影响的数值模拟[J]. 弹道学报, 2017, 29(1): 44-50.
SHI Hong-hui, SUN Ya-ya, ZHOU Yang-jie, el at. Numerical study of the supercavitation flows around underwater vehicles with different surface grooves[J]. Journal of Ballistics, 2017, 29(1): 44-50. (in Chinese)
[7］张鸣远, 景思睿, 李国君，等. 高等工程流体力学[M]. 西安: 西安交通大学出版社, 2006: 310-320.
ZHANG Ming-yuan,JING Si-rui, LI Guo-jun，et al. Advanced fluid mechanics[M]. Xi'an: Xi'an Jiaotong University Press, 2006:310-320. (in Chinese)
[8］聂胜阳, 高正红, 黄江涛. 微分雷诺应力模型在激波分离流中的应用[J]. 空气动力学学报, 2012, 30(1): 52-56.
NIE Sheng-yang, GAO Zheng-hong, HUANG Jiang-tao.Differential Reynolds stress model for shock & separated flow[J]. Acta Aerodynamica Sinica, 2012, 30(1): 52-56. (in Chinese)
[9］施红辉, 周杨洁, 贾会霞,等. 水深和弹体长径比对超空泡弹体阻力系数及空泡形状影响的实验研究[J]. 兵工学报, 2016, 37(11):2029-2036.
SHI Hong-hui, ZHOU Yang-jie, JIA Hui-xia, et al. The effects of water depth and length-to-diameter ratio on drag coefficient and cavity shape of underwater supercavitating projectiles [J]. Acta Armamentarii, 2016, 37(11): 2029-2036. (in Chinese)

[10］周杨洁. 不同表面材料结构的水下航行体表面超空泡的实验研究与数值分析[D]. 杭州：浙江理工大学, 2016：15-30.
ZHOU Yang-jie. Experimental study and numerical analysis on the supercavity of underwater vehicle with different surface materials and structure[D]. Hangzhou: Zhejiang Sci-Tech University, 2016:15-30. (in Chinese)
[11］易文俊, 王中原, 熊天红, 等. 水下高速射弹超空泡减阻特性研究[J]. 弹道学报, 2008, 20(4): 1-4.
YI Wen-jun, WANG Zhong-yuan, XIONG Tian-hong, et al. Research on drag reduction characteristics of a underwater high-speed supercavitation projectile[J]. Journal of Ballistics, 2008, 20(4): 1-4. (in Chinese)
[12］贾会霞, 胡俊辉, 施红辉, 等. 出水超空泡的形状与弗劳德数影响的实验研究[J]. 西安交通大学学报, 2015, 49(3): 67-73.
JIA Hui-xia, HU Jun-hui, SHI Hong-hui, et al.Experimental research on the shape of water-exit supercavity and the effect of froude number [J]. Journal of Xi'an Jiaotong University, 2015,49(3):67-73. (in Chinese)
[13］孙亚亚. 复杂表面形状以及多连发射弹的超空泡流动特性研究[D]. 杭州: 浙江理工大学, 2018.
SUN Ya-ya. Research on supercavitation flows characteristics of complex surface shape and successive projectiles[D]. Hangzhou: Zhejiang Sci-Tech University, 2018. (in Chinese)
[14］何春涛. 典型运动体入水过程多相流动特性研究[D]. 哈尔滨: 哈尔滨工业大学, 2012:100-110.
HE Chun-tao. Study on multiphase flow of typical body during water entry[D]. Harbin: Harbin Institute of Technology, 2012:100-110. (in Chinese)

第39卷
第11期2018 年11月兵工学报ACTA
ARMAMENTARIIVol.39No.11Nov.2018

[1]	张亮, 胡常莉, 吴小安. 超空泡航行体锥段结构对其尾拍运动影响的数值研究[J]. 兵工学报, 2024, 45(3): 828-836.
[2]	刘如石, 郭则庆, 张辉. 尾部形状对超空泡射弹尾拍运动影响的数值研究[J]. 兵工学报, 2023, 44(10): 2984-2994.
[3]	古鉴霄，党建军，黄闯，李代金，刘富强. 衡重参数对超空泡射弹有效射程的影响[J]. 兵工学报, 2022, 43(6): 1376-1386.
[4]	辛大钧，薛琨. 基于人工神经网络的非球形破片阻力系数预测模型[J]. 兵工学报, 2022, 43(5): 1083-1092.
[5]	杜明刚，张金乐，张喜明，孙亚东，毛飞鸿. 履带装甲车辆空气阻力系数试验测定[J]. 兵工学报, 2021, 42(7): 1564-1568.
[6]	张晓光，李斌，党会学，温金鹏，孙潘. 水下航行体充气上浮仿真方法研究[J]. 兵工学报, 2020, 41(7): 1249-1261.
[7]	侯东伯, 王聪, 夏维学, 李宜果, 赵静. 弹性尾缘对超空泡航行体空泡形态与压力脉动特性影响的水洞试验研究[J]. 兵工学报, 2020, 41(3): 534-541.
[8]	侯宇，黄振贵，郭则庆，陈志华，刘如石，罗驭川. 超空泡射弹小入水角高速斜入水试验研究[J]. 兵工学报, 2020, 41(2): 332-341.
[9]	张成举，王聪，曹伟，王金强. 基于无迹卡尔曼滤波的超空泡航行体最优控制研究[J]. 兵工学报, 2019, 40(6): 1235-1243.
[10]	时素果, 王亚东, 杨晓光, 刘乐华. 超空泡航行体运动过程流体动力特性试验研究[J]. 兵工学报, 2019, 40(11): 2266-2271.
[11]	王威，王聪，李聪慧，宋武超. 航行体沾湿区域对空泡尾流结构的影响[J]. 兵工学报, 2019, 40(10): 2111-2118.
[12]	王威, 王聪, 杜严锋, 李聪慧. 周期性阵风流作用下通气超空泡的仿真研究[J]. 兵工学报, 2018, 39(9): 1772-1779.
[13]	陈诚，袁绪龙，邢晓琳，党建军. 预置舵角下超空泡航行体倾斜入水弹道特性研究[J]. 兵工学报, 2018, 39(9): 1780-1785.
[14]	陈诚，袁绪龙，党建军，徐强. 超空泡航行器20°角倾斜入水冲击载荷特性试验研究[J]. 兵工学报, 2018, 39(6): 1159-1164.
[15]	胡明勇，张志宏，刘巨斌，孟庆昌. 低亚声速射弹垂直入水的流体与固体耦合数值计算研究[J]. 兵工学报, 2018, 39(3): 560-568.

水下连发射弹的超空泡流动特性研究

Research on the Characteristics of Supercavitating Flows Caused by Underwater Continuously Fired Projectiles

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价