大幅面太阳全光谱辐照系统的设计

doi:10.3969/j.issn.1000-1093.2019.10.023

兵工学报 ›› 2019, Vol. 40 ›› Issue (10): 2161-2169.doi: 10.3969/j.issn.1000-1093.2019.10.023

大幅面太阳全光谱辐照系统的设计

刘建河¹，白海龙¹，赵玉丹²

（1.长春理工大学机电工程学院，吉林长春 130022； 2.长春理工大学理学院，吉林长春 130022）

收稿日期:2019-01-04 修回日期:2019-01-04 上线日期:2019-12-18
作者简介:刘建河（1976—），男，副研究员。E-mail: a_liu100@163.com
基金资助:
吉林省科技发展计划重点项目（20170101118JC）

The Design of Large-scale Full Solar Spectrum Irradiation System for Solar Simulator

LIU Jianhe¹, BAI Hailong¹, ZHAO Yudan²

(1.College of Mechatronical Engineering, Changchun University of Science and Technology, Changchun 130022, Jilin, China; 2.College of Science, Changchun University of Science and Technology, Changchun 130022, Jilin, China)

Received:2019-01-04 Revised:2019-01-04 Online:2019-12-18

摘要/Abstract

摘要： 大幅面太阳全光谱辐照系统是太阳模拟器的重要组成部分，辐照不均匀度是其关键技术指标之一，在传统全光谱辐照系统中存在着难以达到国家标准、光源光谱匹配性差等技术难题。结合大幅面太阳模拟器的研究现状，设计了一种全光谱辐照系统。利用光学仿真软件Zemax对所设计的全光谱辐照系统辐照均匀性进行仿真，提出了辐照度衰减模式的新概念，并以此为基础对全光谱辐照系统辐照不均匀度进行了优化。光源采用瑞士Solaronix公司生产的Plasma光源，经过测试光谱达到国际电工委员会标准A级，光源谱段内辐照度用光谱辐射计进行测试。结果表明，在辐照度为280 W/m²时，辐照度衰减模式在未启动和启动时辐照不均匀度分别为8.4%和5.7%，参考国家标准GB/T12637—1990太阳模拟器通用规范，在2 400 mm×6 000 mm有效辐照面内其辐照均匀度满足规范C级标准，接近B级标准。

关键词: 太阳全光谱, 大幅面辐照系统, 照度衰减模式, 辐照不均匀度, 辐照不稳定度

Abstract: Large-scale full solar spectrum irradiation system is an important part of the solar simulator. Irradiation non-uniformity is one of the key technical indexes for the large-scale solar simulator. Some technical problems about difficultly meeting the national standard and the poor optical spectra matching property of light sources exist in traditional solar simulators. Regarding the present issues of the large-scale solar simulators, a full-spectrum irradiation system was designed, and the irradiation uniformity of the system was simulated by using the software Zemax. An innovative concept, irradiance decay pattern, is put forward, and the irradiation uniformity is optimized in this way. A plasma light source produced by So-laronix, Switzerland is used, and the spectrum of full-spectrum solar irradiation system can reach Level A of IEC standard. The irradiance of the proposed system was tested by using a spectral radiometer in the full-spectrum scope. The test results show, when the irradiance is 280 W/m², the irradiance nonuniformity is 5.7% if the irradiance decay pattern is switched on, or 8.4% if the pattern is off. Referring to the national standard GB/T12637—90 General specification for solar simulator, in the effective radiation area of 2 400 mm×6 000 mm, the irradiance uniformity is better than Level C, and almost reaches Level B. Key

Key words: fullsolarspectrum, large-scaleirradiationsystem, irradiancedecaypattern, irradiancenon-uniformity, irradianceinstability

中图分类号:

TH744.11⁺7

刘建河，白海龙，赵玉丹. 大幅面太阳全光谱辐照系统的设计[J]. 兵工学报, 2019, 40(10): 2161-2169.

LIU Jianhe, BAI Hailong, ZHAO Yudan. The Design of Large-scale Full Solar Spectrum Irradiation System for Solar Simulator[J]. Acta Armamentarii, 2019, 40(10): 2161-2169.

参考文献

［1］苏拾, 张国玉, 付芸, 等. 太阳模拟器的新发展[J].激光与光电子学进展, 2012, 49(7): 17-24.
SU S, ZHANG G Y, FU Y, et al. New development of solar si-mulator[J]. Laser & Optoelectronics Progress, 2012, 49(7): 17- 24.(in Chinese)
[2］任建岳, 苏克强, 王兵, 等. 真空应用太阳模拟灯及其灯阵的研制[J]. 光学精密工程, 2010, 18(8):1699-1706.
REN J Y, SU K Q, WANG B, et al. Development of vacuum application solar simulation Xe flash-lamp array[J]. Optics and Precision Engineering, 2010, 18(8): 1699-1706. (in Chinese)
[3］ SWITZER G W, MCFARLAND T A, BUCZALA R K, et al. LED-based solar simulator system and method of use: WO/2015/048591[P].2015-04-02.
[4］李俊麟, 张黎明, 司孝龙，等.扫描式氙灯太阳模拟器十维扫描系统[J].光学精密工程, 2017, 25(2): 358-366.
LI J L, ZHANG L M, SI X L, et al. Ten-dimensional scanning system of scanning xenon lamp solar simulator[J]. Optics and Precision Engineering, 2017, 25(2): 358-366. (in Chinese)
[5］苏拾, 张国玉, 王凌云, 等. 基于LED阵列光源的太阳模拟器[J]. 光学精密工程, 2018, 26(2): 307-315.
SU S, ZHANG G Y, WANG L Y, et al. Solar simulator based on LED array light source[J]. Optics and Precision Engineering, 2018, 26(2)： 307-315. (in Chinese)
[6］张鹏嵩, 张博伦, 王丹艺, 等. 高准直太阳模拟器研制[J].航天器环境工程, 2018, 35(1):71-75.
ZHANG P S, ZHANG B L, WANG D Y, et al. Development of a high collimated solar simulator[J]. Spacecraft Environment Engineering, 2018, 35(1): 71-75. (in Chinese)
[7］刘石, 张利云, 孙高飞, 等. 大光斑高均匀度发散式太阳模拟器设计[J]. 红外与激光工程, 2018, 47(4):222-230.
LIU S, ZHANG L Y,SUN G F, et al. Design of divergence solar simulator with large irradiated surface and high uniformity[J]. Infrared and Laser Engineering, 2018, 47(4):222-230. (in Chinese)
[8］杨林华, 李竑松. 国外大型太阳模拟器研制技术概述[J].航天器环境工程, 2009, 26(2):162-167.
YANG L H, LI H S. The development of large solar simulators in the world[J]. Spacecraft Environment Engineering, 2009, 26(2): 162-167. (in Chinese)
[9］张容, 李竑松, 向艳红, 等. KFTA 太阳模拟器研制[J].航天器环境工程, 2009, 26(6):548-553．
ZHANG R, LI H S, XIANG Y H, et al. Development of KFTA solar simulator[J]. Spacecraft Environment Engineering, 2009, 26(6): 548-553. (in Chinese)

[10］刘宏波. 太阳模拟技术[J].光学精密工程, 2001, 9(2):177-181.
LIU H B. Solar simulation technology[J]. Optics and Precision Engineering, 2001, 9(2): 177-181.(in Chinese)
[11］许杰, 蒋山平, 杨林华. 一种氙灯灯阵的软件仿真设计[C]∥2009年航天五院科技委环境工程与可靠性专业组学术交流会. 北京:中国空间技术研究院, 2009: 17-20.
XU J, JIANG S P, YANG L H. Design of a new type of software simulation[C]∥Proceedings of 2009 Academic Meeting of Environmental Engineering and Reliability Professional Group of Science and Technology Commission of Aerospace Academy. Beijing: China Academy of Space Technology, 2009: 17-20. (in Chinese)
[12］国际电工委员会. 地面太阳辐射模拟试验规范: IEC 68-2-5[S]. 北京:中国标准出版社, 1975.
International Electrotechnical Commission. The standard for solar radiation simulating test on earth: IEC 68-2-5[S]. Beijing: Standards Press of China, 1975. (in Chinese)
[13］祝振敏. 提高彩色视觉测量对比度的研究[D]. 天津: 天律大学, 2011.
ZHU Z M. Research on the enhancement of measurement contrast technology for color vision measurement[D]. Tianjin: Tianjin University, 2011. (in Chinese)
[14］ VOGL T P, LINTNER L C, PEGIS R J. Semiautomatic design of illuminating systems[J]. Applied Optics, 1972, 11(5): 1087-1090.
[15］ MENG Q L, LI Y P, GU Y X. Dynamic mesh-based analysis of dynamic irradiance characteristics of solar simulator[J]. Optik, 2015, 126(23):4658-4664.
[16］刘百芬, 金小龙, 祝振敏. 基于LED阵列与漫反射自由曲面的均匀照明光源设计[J]. 应用光学, 2014, 35(4):598-602.
LIU B F,JIN X L, ZHU Z M. Uniform illumination design based on LED array and diffuse reflection freeform surface[J]. Journal of Applied Optics, 2014, 35(4):598-602.(in Chinese)
[17］ SUFFERN K.光线跟踪算法技术[M]. 刘天慧, 译. 北京:清华大学出版社, 2011.
SUFFERN K. Ray tracing from the ground up[M]. LIU T H, translated. Beijing: Tsinghua University Press, 2011.(in Chinese)
[18］气象太阳模拟器: GB/T33707—2017[S]. 北京:中国标准出版社, 2017.
Meteorological solar simulator: GB/T33707—2017[S]. Beijing: Standards Press of China, 2017.(in Chinese)
[19］袁亚飞, 刘民, 杨亦强. 太阳模拟器辐照不均匀性测试系统的研制[C]∥第十七届全国测控、计量与仪器仪表学术年会. 厦门:中国航天科技集团公司五院五一四所, 2007:243-245.
YUAN Y F, LIU M, YANG Y Q. Development of the test system for irradiation non-uniformity of solar simulator [C]∥Proceedings of the 17th China Annual Conference on Measurement, Control, Metrology and Instrumentation. Xiamen: 514th Institute, China Aerospace Science and Technology Corporation, 2007:243-245. (in Chinese)
[20］任建岳, 苏克强, 王兵, 等. 真空应用太阳模拟灯及其灯阵的研制[J]. 光学精密工程, 2010, 18(8):1699-1707.
REN J Y, SU K Q, WANG B, et al. Development of vacuum application solar simulation Xe flash-lamp array[J]. Optics and Precision Engineering, 2010, 18(8):1699-1707.(in Chinese)
[21］太阳模拟器通用规范: GB/T12637—1990 [S].北京:中国标准出版社, 1990.
General specification for solar simulator: GB/T12637—1990[S]. Beijing: Standards Press of China, 1990.(in Chinese)
[22］王元, 张林华. 一种新型全光谱太阳模拟器设计[J]. 太阳能学报, 2006, 27(11): 1132-1136．
WANG Y, ZHANG L H. Design of a new type of full-spectrum solar simulator[J]. Acta Energiae Solaris Sinica, 2006, 27(11): 1132-1136.(in Chinese)

第40卷
第10期2019 年10月兵工学报ACTA
ARMAMENTARIIVol.40No.10Oct.2019

大幅面太阳全光谱辐照系统的设计

The Design of Large-scale Full Solar Spectrum Irradiation System for Solar Simulator

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价