Al/Ni粉末复合材料冲击反应细观机制

doi:10.12382/bgxb.2021.0488

摘要/Abstract

摘要： 为阐明含能结构材料冲击反应机理，开展以Al/Ni粉末复合材料为代表的含能结构材料冲击反应细观模拟研究。基于Al/Ni粉末复合材料的扫描电镜照片建立细观有限元模型，并结合Mie-Grüneisen状态方程描述Al/Ni粉末复合材料冲击压缩行为。在此基础上，基于反应扩散模型建立考虑多组分固相反应的Al/Ni粉末复合材料冲击反应细观模型，分析细观尺度上物质输运过程、冲击反应演化规律及冲击波传播特性。研究结果表明：Al/Ni粉末复合材料在冲击压缩速度(即粒子速度)为400 m/s时仅发生了微弱的化学反应，且化学反应程度随着冲击压缩速度的增大的加剧；化学反应最初发生于Al-Ni界面处，然后垂直于界面发展；冲击反应将引起材料冲击温度和压力的增高，同时对冲击波的传播起到强化作用。

关键词: 含能结构材料, Al/Ni粉末复合材料, 冲击反应, 细观机制, 力-热-化学耦合

Abstract: Mesoscale simulation of the energy release behaviors of Al/Ni powder composites is conducted to clarify the mechanism of shock reaction. A mesoscale model is established based on the Scanning Electron Microscope image of the Al/Ni composite to reveal the microstructure. The dynamic behaviors of both Al and Ni particles are described using Mie-Grüneisen equation of state. Furthermore, a shock reaction model for the solid-phase reaction between multiple components is established based on the reaction diffusion model. The shock pressure, temperature distribution and propagation of shock waves are obtained to analyze the dynamic response of the Al/Ni powder compaction. On the other hand, the evolution of reactants and reaction products are obtained to analyze the mass diffusion process, evolution of the chemical reaction, and the Al/Ni powder composite on mesoscale. The results show that the Al and Ni particles deform violently after compression, causing high shock pressure and temperature in the Al/Ni powder composites. The material Ni is transported into Al particles due to the concentration gradient and shock-induced temperature rise. The chemical reaction in the Al/Ni powder composite will be initiated by a critical condition with the particle velocity at about 400 m/s. Once the particle velocity exceeds the critical value, the reaction will be intensified with the increase of particle velocity. The above results agree well with related experimental results. The reaction product is first produced at the Al-Ni interface and then grows perpendicularly to the interface, accompanied by the consumption of reactants. Therefore, the shock reaction is initiated at and developed from the Al-Ni interface. Furthermore, the shock reaction makes additional contribution to the shock pressure and temperature, especially near the Al-Ni interface. The shock velocity of shock waves in the Al/Ni powder compaction also exceeds the value without considering the reaction.

Key words: energeticstructuralmaterials, Al/Nipowdercomposites, shockreaction, mesoscalemechanism, mechanical-thermo-chemicalcoupling

中图分类号:

O382

熊玮，张先锋，陈海华，刘闯，谈梦婷. Al/Ni粉末复合材料冲击反应细观机制[J]. 兵工学报, 2022, 43(8): 1823-1834.

XIONG Wei, ZHANG Xianfeng, CHEN Haihua, LIU Chuang, TAN Mengting. Mesoscale Mechanism of the Shock Reaction of Al/Ni Powder Composites[J]. Acta Armamentarii, 2022, 43(8): 1823-1834.

参考文献

［1］ MARTIN M. Processing and characterization of energetic and structural behavior of nickel aluminum with polymer binders[D].Atlanta, GA, US: Georgia Institute of Technology, 2005:41-45.
[2］ ZHANG X F, SHI A S, QIAO L, et al. Experimental study on impact-initiated characters of multifunctional energetic structural materials [J]. Journal of Applied Physics, 2013, 113(8): 083508.
[3］刘晓俊, 任会兰. 一种反应材料制备及准静态力学特性研究[J]. 北京理工大学学报, 2016, 36(4): 365-369.
LIU X J, REN H L. Preparation and quasi-static mechanical properties of reactive material[J]. Transactions of Beijing Institute of Technology, 2016, 36(4): 365-369. (in Chinese)
[4］ WU Q, ZHANG Q M, LONG R R, et al. Potential space debris shield structure using impact-initiated energetic materials composed of polytetrafluoroethylene and aluminum[J]. Applied Physics Letters, 2016, 108(10): 101903.
[5］肖艳文, 徐峰悦, 郑元枫, 等. 活性材料弹丸碰撞油箱引燃效应实验研究[J]. 北京理工大学学报, 2017, 37(6): 557-561.
XIAO Y W, XU F Y, ZHENG Y F, et al. Experimental study on ignition effects of fuel-filled tank impacted by reactive material projectile[J]. Transactions of Beijing Institute of Technology, 2017, 37(6): 557-561. (in Chinese)
[6］肖艳文, 徐峰悦, 余庆波, 等. 高密度活性破片碰撞双层靶毁伤效应[J]. 科技导报, 2017, 35(10): 99-103.
XIAO Y W, XU F Y, YU Q B, et al. Damage of double-spaced plates by reactive material fragment impact[J]. Science and Technology Review, 2017, 35(10): 99-103. (in Chinese)
[7］张雪朋, 肖建光, 余庆波, 等. 活性药型罩聚能装药破甲后效超压特性[J]. 兵工学报, 2016, 37(8): 1388-1394.
ZHANG X P, XIAO J G, YU Q B, et al. Armor penetration aftereffect overpressure produced by reactive material liner shaped charge[J]. Acta Armamentarii, 2016, 37(8): 1388-1394. (in Chinese)
[8］潘文强, 付代轩, 赖康华, 等. 含能射孔弹双层药型罩穿孔性能研究[J]. 爆破器材, 2017, 46(2): 31-34.
PAN W Q, FU D X, LAI K H, et al. Study on penetration performance of bi-layer liner in energetic penetrating charge[J]. Explosive Materials, 2017, 46(2): 31-34. (in Chinese)
[9］汪德武, 任柯融, 江增荣, 等. 活性材料冲击释能行为研究进展[J]. 爆炸与冲击, 2021, 41(3): 86-102.
WANG D W, REN K R, JIANG Z R, et al. Shock-induced energy release behaviors of reactive materials[J]. Explosion and Shock Waves, 2021, 41(3): 86-102. (in Chinese)
[10］ REDING D J. Multiscale chemical reactions in reactive powder metal mixtures during shock compression[J]. Journal of Applied Physics, 2010, 108(2): 024905.
[11］ BOSLOUGH M B. A thermochemical model for shock-induced reactions (heat detonations) in solids[J]. The Journal of Chemical Physics, 1990, 92(3): 1839-1848.
[12］ REEVES R V, MUKASYAN A S, SON S F. Thermal and impact reaction initiation in Ni/Al heterogeneous reactive systems[J]. The Journal of Physical Chemistry C, 2010, 114(35): 14772-14780.
[13］武强. 含能材料防护结构超高速撞击特性研究[D]. 北京:北京理工大学, 2016.
WU Q. Dynamic characteristics of energetic materials shield induced by hypervelocity impact[D]. Beijing:Beijing Institute of Technology, 2016. (in Chinese)
[14］王璐瑶, 蒋建伟, 李梅, 等. 钨锆铪活性合金破片冲击释能行为实验研究[J]. 兵工学报, 2019, 40(8): 1603-1610.
WANGL Y, JIANG J W, LI M, et al. Experimental research on energy release behavior of W/Zr/Hf alloy fragment[J]. Acta Armamentarii, 2019, 40(8): 1603-1610. (in Chinese)
[15］刘晓俊, 任会兰, 宁建国. 不同配比W/Zr活性材料冲击反应实验研究[J]. 材料工程, 2017, 45(4): 77-83.
LIU X J, REN H L, NING J G. Experimental study on impact response of W/Zr reactive materials with different proportions[J]. Journal of Materials Engineering, 2017, 45(4): 77-83. (in Chinese)
[16］ EAKINS D E, THADHANI N N. Mesoscale simulation of the configuration-dependent shock-compression response of Ni+ Al powder mixtures[J]. Acta Materialia, 2008, 56(7): 1496-1510.
[17］ VITALI E, WEI C T, BENSON D J, et al. Effects of geometry and intermetallic bonding on the mechanical response, spalling and fragmentation of Ni-Al laminates[J]. Acta Materialia, 2011, 59(15): 5869-5880.
[18］ AUSTIN R A, MCDOWELL D L, BENSON D J. Mesoscale simulation of shock wave propagation in discrete Ni/Al powder mixtures[J]. Journal of Applied Physics, 2012, 111(12): 123511.
[19］武强, 龚自正, 张庆明, 等. 含能活性材料防护结构超高速撞击特性数值模拟研究[J]. 振动与冲击, 2021, 40(11): 202-210.
WU Q, GONG Z Z, ZHANG Q M, et al. Numerical simulation of hypervelocity impact characteristics of energetic active material protective structure[J]. Journal of Vibration and Shock, 2021, 40(11): 202-210. (in Chinese)
[20］ REN K R, CHEN J, QING H, et al. Study on shock‐induced chemical energy release behavior of Al/W/PTFE reactive material with mechanical-thermal-chemical coupling SPH approach[J]. Propellants, Explosives, Pyrotechnics, 2020, 45(12): 1937-1948.
[21］张雪朋, 肖建光, 余庆波, 等. 活性药型罩聚能装药作用混凝土靶毁伤效应[J]. 北京理工大学学报, 2016, 36(12): 1211-1215.
ZHANG X P, XIAO J G, YU Q B, et al. Demolition effect of reactive material liner shaped charge against concrete target[J]. Transactions of Beijing Institute of Technology, 2016, 36(12): 1211-1215.(in Chinese)
[22］ DUNBAR E, THADHANI N N. High-pressure shock activation and mixing of nickel-aluminum powder mixtures[J]. Journal of Materials Science, 1993, 28: 2903-2914.
[23］ XIONG W, ZHANG X F, ZHENG L, et al. The shock-induced chemical reaction behaviour of Al/Ni composites by cold rolling and powder compaction[J]. Journal of Materials Science, 2019, 54(8): 6651-6667.
[24］ XIONG W, ZHANG X F, TAN M, et al. The energy release characteristics of shock-induced chemical reaction of Al/Ni composites[J]. The Journal of Physical Chemistry C, 2016, 120(43): 24551-24559.
[25］ MEYERS M A. Dynamic behavior of materials[M]. New York, NY, US: John wiley & sons, 1994.
[26］ LEMONS D S, LUND C M. Thermodynamics of high temperature, Mie-Gruneisen solids[J]. American Journal of Physics, 1999, 67(12): 1105-1108.
[27］ YIN S, SUO X K, XIE Y C, et al. Effect of substrate temperature on interfacial bonding for cold spray of Ni onto Cu[J]. Journal of Materials Science, 2015, 50(22): 7448-7457.
[28］戚正风. 固态金属中的扩散与相变[M]. 北京:机械工业出版社, 1998.
QI Z F. The diffusion and phase change in solid metals[M]. Beijing: China Machine Press, 1998. (in Chinese)
[29］ LOMOV I, HERBOLD E B, AUSTIN R A. Mesoscale studies of mixing in reactive materials during shock loading[C]∥Proceedings of the 7th Biennial Conference of the American-Physical-Society-Topical-Group on Shock Compression of Condensed Matter. Chicago, IL, US: American Institute of Physics, 2012.
[30］ SIVA P A V S, SUMIT B. Numerical modelling of shock-induced chemical reactions (SICR) in reactive powder mixtures using smoothed particle hydrodynamics (SPH)[J]. Modelling and Simulation in Materials Science and Engineering, 2015, 23(7): 075005.