考虑弹体材料硬度的Jones质量损失修正模型及AerMet100弹体高速侵彻验证

吴海军; 王可慧; 李明; 杨慧; 沈子楷; 戴湘晖; 王伟光; 张雨平; 周刚

doi:10.12382/bgxb.2025.0741

您当前的位置：

首页 >

文章列表页 >

考虑弹体材料硬度的Jones质量损失修正模型及AerMet100弹体高速侵彻验证

更新时间：2026-02-10

- 考虑弹体材料硬度的Jones质量损失修正模型及AerMet100弹体高速侵彻验证
- A Modified Jones Mass Loss Model Considering the Projectile Material Hardness and Validation via High-speed Penetration of AerMet100 Projectiles
- 兵工学报 2025年46卷第S2期页码：250741
- 作者机构：
  
  西北核技术研究所, 陕西西安 710024
- 作者简介：
  
  * 邮箱: springaround@163.com
- 基金信息：
- DOI：10.12382/bgxb.2025.0741
  中图分类号：
- 收稿：2025-08-15，
  
  网络首发：2026-02-03，
  
  纸质出版：2025
- 稿件说明：
移动端阅览
吴海军, 王可慧, 李明, 等. 考虑弹体材料硬度的Jones质量损失修正模型及AerMet100弹体高速侵彻验证[J]. 兵工学报, 2025,46(S2):250741.

Haijun WU, Kehui WANG, Ming LI, et al. A Modified Jones Mass Loss Model Considering the Projectile Material Hardness and Validation via High-speed Penetration of AerMet100 Projectiles[J]. Acta Armamentarii, 2025, 46(S2): 250741.
吴海军, 王可慧, 李明, 等. 考虑弹体材料硬度的Jones质量损失修正模型及AerMet100弹体高速侵彻验证[J]. 兵工学报, 2025,46(S2):250741. DOI： 10.12382/bgxb.2025.0741.

Haijun WU, Kehui WANG, Ming LI, et al. A Modified Jones Mass Loss Model Considering the Projectile Material Hardness and Validation via High-speed Penetration of AerMet100 Projectiles[J]. Acta Armamentarii, 2025, 46(S2): 250741. DOI： 10.12382/bgxb.2025.0741.

摘要

高速侵彻过程中弹体的质量损失显著影响侵彻能力

现有质量损失模型未充分考虑弹体材料硬度的影响。采用Silling经验公式分析大量高速侵彻弹体质量损失实验数据

指出混凝土骨料硬度和弹体材料硬度是影响弹体质量损失的重要因素

而弹体材料硬度对弹体质量损失的影响较混凝土骨料硬度更大

拟合得到弹体材料硬度对弹体质量损失的影响规律。在Jones质量损失模型中引入混凝土骨料硬度修正系数

和弹体材料硬度修正系数

修正模型的弹体质量损失计算结果与不同弹靶组合的实验结果均能吻合较好。采用二级轻气炮开展1200~2200m/s速度范围的AerMet100弹体高速侵彻实验

获取不同速度下的无量纲侵深和质量损失

进一步验证修正模型对更高硬度弹体、更高侵彻速度情况的有效性。实验发现AerMet100弹体相对于其他材料具有更高的极限侵彻深度和更低的质量损失率

表明提高弹体材料硬度能够减小弹体侵蚀程度

提高高速侵彻能力。

Abstract

The significant mass loss of projectile during high-speed penetration has a significant affect on penetration capability.However

the existing mass-loss models fail to adequately take into account the influence of projectile material hardness.A large amount of experimental data on the mass loss of projectiles during high-speed penetration is analyzed using the Silling empirical relationship.It is found that the hardnesses of concrete aggregates and projectile materials are the important factors

affecting the mass loss of projectiles.The influence of the hardness of projectile material on the mass loss of projectile is greater than that of the hardness of concrete aggregates.The influence law of projectile material hardness on the mass loss is is obtained through fitting.The hardness correction coefficient

of concrete aggregate and the correction coefficient

of projectile material hardness are introduced in the Jones model.The calculated results of the modified model are in good agreement with the experimental results of different projectile-target combinations.Then

a two-stage light gas gun is used to conduct the high-speed penetration experiments of AerMet100 projectile in the speed range of 1200-2200m/s.The dimensionless penetration depth and mass loss at different penetration speeds are obtained to further verify the effectiveness of the modified model under the conditions of higher hardness projectile and higher penetration speeds.Meanwhile

it is found that the AerMet100 projectile has a higher penetration depth and lower mass loss compared to other materials

indicating that the hardness of projectile material can be increased to reduce the degree of projectile erosion and improve the high-speed penetration ability.

关键词

Keywords

references

FORRESTAL M J , FREW D J , HANCHAK S J , et al. Penetration of grout and concrete targets with ogive-nose steel projectiles [J ] . International Journal of Impact Engineering , 1996 , 18 ( 5 ): 465 - 476 .

FREW D J , HANCHAK S J , GREEN M L , et al. Penetration of concrete targets with ogive-nose steel rods [J ] . International Journal of Impact Engineering , 1998 , 21 ( 6 ): 489 - 497 .

赵晓宁 . 高速弹体对混凝土侵彻效应研究 [D ] . 南京 : 南京理工大学 , 2011 .

ZHAO X N . Study on the effect of projectiles high-velocity normal penetrating into concrete targets [D ] . Nanjing : Nanjing University of Science & Technology , 2011 . (in Chinese)

何翔 , 徐翔云 , 孙桂娟 , 等 . 弹体高速侵彻混凝土的效应实验 [J ] . 爆炸与冲击 , 2010 , 30 ( 1 ): 1 - 6 .

HE X , XU X Y , SUN G J , et al. Experimental investigation on projectiles’ high-velocity penetration into concrete targets [J ] . Explosion and Shock Waves , 2010 , 30 ( 1 ): 1 - 6 . (in Chinese)

杨建超 , 左新建 , 何翔 , 等 . 弹体高速侵彻混凝土质量侵蚀实验研究 [J ] . 实验力学 , 2012 , 27 ( 1 ): 122 - 127 .

YANG J C , ZUO X J , HE X , et al. Experimental study of projectile mass loss in high velocity penetration of concrete target [J ] . Journal of Experimental Mechanics , 2012 , 27 ( 1 ): 122 - 127 . (in Chinese)

武海军 , 黄风雷 , 王一楠 , 等 . 高速侵彻混凝土弹体头部侵蚀终点效应实验研究 [J ] . 兵工学报 , 2012 , 33 ( 1 ): 48 - 55 .

WU H J , HUANG F L , WANG Y N , et al. Experimental investigation on projectile nose eroding effect of high-velocity penetration into concrete [J ] . Acta Armamentarii , 2012 , 33 ( 1 ): 48 - 55 . (in Chinese)

闪雨 . 弹体非正侵彻混凝土质量侵蚀与运动轨迹研究 [D ] . 北京 : 北京理工大学 , 2015 .

SHAN Y . Investigation on the mass abrasion and motion of the projectile non-normal penetrating into concrete [D ] . Beijing : Beijing Institute of Technology , 2015 . (in Chinese)

张雪岩 , 武海军 , 李金柱 , 等 . 弹体高速侵彻两种强度混凝土靶的对比研究 [J ] . 兵工学报 , 2019 , 40 ( 2 ): 276 - 283 .

ZHANG X Y , WU H J , LI J Z , et al. Comparative study of projectiles penetrating into two kinds of concrete targets at high velocity [J ] . Acta Armamentarii , 2019 , 40 ( 2 ): 276 - 283 . (in Chinese)

宋梅利 , 王晓鸣 , 李文彬 , 等 . 弹头形状对高速侵彻效应的影响 [J ] . 弹道学报 , 2014 , 26 ( 3 ): 66 - 71 .

SONG M L , WANG X M , LI W B , et al. Influence of projectiles nose shape on high speed penetration effect [J ] . Journal of Ballistics , 2014 , 26 ( 3 ): 66 - 71 . (in Chinese)

郭磊 , 何勇 , 潘绪超 , 等 . 高速侵彻混凝土弹体侵蚀效应试验研究 [J ] . 实验力学 , 2020 , 35 ( 1 ): 82 - 90 .

GUO L , HE Y , PAN X C , et al. Experimental study on mass loss of projectile subjected to high-velocity penetration into concrete target [J ] . Journal of Experimental Mechanics , 2020 , 35 ( 1 ): 82 - 90 . (in Chinese)

SILLING S A , FORRESTAL M J . Mass loss from abrasion on ogive-nose steel projectiles that penetrate concrete targets [J ] . International Journal of Impact Engineering , 2007 , 34 ( 11 ): 1814 - 1820 .

JONES S E , FOSTER J C , TONESS O A , et al. An estimate for mass loss from high velocity steel penetrators [C ] // Proceedings of ASME 2002 Pressure Vessels and Piping Conference.New York,NY,US:ASME,2002.

何丽灵 , 陈小伟 , 范瑛 . 先进钻地弹高速侵彻实验中质量磨蚀金相分析 [J ] . 爆炸与冲击 , 2012 , 32 ( 5 ): 515 - 522 .

HE L L , CHEN X W , FAN Y . Metallographic observation of reduced-scale advanced EPW after high-speed penetration [J ] . Explosion and Shock Waves , 2012 , 32 ( 5 ): 515 - 522 . (in Chinese)

GUO L , HE Y , ZHANG X F , et al. Study mass loss at microscopic scale for a projectile penetration into concrete [J ] . International Journal of Impact Engineering , 2014 , 72 : 17 - 25 .

陈小伟 , 杨世全 , 何丽灵 . 动能侵彻弹体的质量侵蚀模型分析 [J ] . 力学学报 , 2009 , 41 ( 5 ): 739 - 747 .

CHEN X W , YANG S Q , HE L L . Modeling on mass abrasion of kinetic energy penetrator [J ] . Chinese Journal of Theoretical and Applied Mechanics , 2009 , 41 ( 5 ): 739 - 747 . (in Chinese)

CHEN X W , HE L L , YANG S Q . Modeling on mass abrasion of kinetic energy penetrator [J ] . European Journal of Mechanics,A/Solids , 2010 , 29 ( 1 ): 7 - 17 .

欧阳昊 , 陈小伟 . 混凝土骨料对高速侵彻弹体质量侵蚀的影响分析 [J ] . 爆炸与冲击 , 2019 , 39 ( 7 ): 64 - 73 .

OUYANG H , CHEN X W . Analysis of mass abrasion of high-speed penetrator influenced by aggregate in concrete target [J ] . Explosion and Shock Waves , 2019 , 39 ( 7 ): 64 - 73 . (in Chinese)

杨华伟 , 晋小超 , 王志华 , 等 . 基于Jones模型的弹体质量损失参数分析 [J ] . 中国科学:技术科学 , 2016 , 46 ( 4 ): 368 - 376 .

YANG H W , JIN X C , WANG Z H , et al. Analysis of influence parameters on mass loss of projectiles based on Jones abrasion model [J ] . Science China (Technological Sciences) , 2016 , 46 ( 4 ): 368 - 376 . (in Chinese)

HE L L , CHEN X W , HE X . Parametric study on mass loss of penetrators [J ] . Acta Mechanica Sinica , 2010 , 26 ( 4 ): 585 - 597 .

HE L L , CHEN X W , XIA Y M . Representation of nose blunting of projectile into concrete target and two reduction suggestions [J ] . International Journal of Impact Engineering , 2014 , 74 : 132 - 144 .

李杰 , 王明洋 , 李海波 , 等 . 超高速动能武器侵彻岩石的毁伤评估与工程防护 [J ] . 现代应用物理 , 2018 , 9 ( 4 ): 41 - 47 ,65.

LI J , WANG M Y , LI H B , et al. The damage effect evaluation and protection of hypervelocity kinetic energy weapon penetrating rocks [J ] . Modern Applied Physics , 2018 , 9 ( 4 ): 41 - 47 ,65. (in Chinese)

卢正操 , 张元迪 , 文鹤鸣 , 等 . 长杆弹侵彻半无限混凝土靶的理论研究 [J ] . 现代应用物理 , 2018 , 9 ( 4 ): 040102 .

LU Z C , ZHANG Y D , WEN H M , et al. Theoretical study on the penetration of long rods into semi-infinite concrete targets [J ] . Modern Applied Physics , 2018 , 9 ( 4 ): 040102 . (in Chinese)

何丽灵 , 陈小伟 . 高速侵彻混凝土弹体的形状演化模拟 [J ] . 力学学报 , 2011 , 43 ( 4 ): 707 - 715 .

HE L L , CHEN X W . Simulation of projectile nose during high-speed penetration into concrete [J ] . Chinese Journal of Theoretical and Applied Mechanics , 2011 , 43 ( 4 ): 707 - 715 . (in Chinese)

浏览量

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

复合靶板抗侵彻性能结构优化

带预侵蚀头部弹体的高速侵彻性能

高速侵彻混凝土弹体头部侵蚀终点效应实验研究

Recent studies on potential accident-tolerant fuel-cladding systems in light water reactors

Spin coating of TPB film on acrylic substrate and measurement of its wavelength shifting efficiency