基于特征模型的5阶关节伺服系统扰动补偿策略

张天艺; 郑颖; 裘信国; 季行健; 金晓航

doi:10.12382/bgxb.2022.0941

您当前的位置：

首页 >

文章列表页 >

基于特征模型的5阶关节伺服系统扰动补偿策略

更新时间：2025-08-18

- 基于特征模型的5阶关节伺服系统扰动补偿策略
- Disturbance Compensation Strategy for Fifth-order Joint Servomechanism Based on Characteristic Model
- 兵工学报 2024年45卷第1期页码：276-287
- 作者机构：
  
  浙江工业大学机械工程学院, 浙江杭州 310014
- 作者简介：
  
  * 邮箱: greenzy@zjut.edu.cn
- 基金信息：
  
  国家重点研发计划项目(2022YFE0198900);浙江省自然科学基金项目(LQ19E050009);浙江省基础公益研究专项项目(LGG22E050032)
- DOI：10.12382/bgxb.2022.0941
  中图分类号：
- 收稿：2022-10-17，
  
  网络出版：2024-02-06，
  
  纸质出版：2024-01-30
- 稿件说明：
移动端阅览
张天艺, 郑颖, 裘信国, 等. 基于特征模型的5阶关节伺服系统扰动补偿策略[J]. 兵工学报, 2024,45(1):276-287.

Tianyi ZHANG, Ying ZHENG, Xinguo QIU, et al. Disturbance Compensation Strategy for Fifth-order Joint Servomechanism Based on Characteristic Model[J]. Acta Armamentarii, 2024, 45(1): 276-287.
张天艺, 郑颖, 裘信国, 等. 基于特征模型的5阶关节伺服系统扰动补偿策略[J]. 兵工学报, 2024,45(1):276-287. DOI： 10.12382/bgxb.2022.0941.

Tianyi ZHANG, Ying ZHENG, Xinguo QIU, et al. Disturbance Compensation Strategy for Fifth-order Joint Servomechanism Based on Characteristic Model[J]. Acta Armamentarii, 2024, 45(1): 276-287. DOI： 10.12382/bgxb.2022.0941.

摘要

针对工业机器人关节伺服系统负载时变和模型不确定性问题

提出将线性扩张状态观测器和基于特征模型的全系数自适应控制相结合的控制策略。建立双惯量柔性关节动力学模型并得到关节伺服系统5阶扩张状态方程。基于该模型设计5阶线性扩张状态观测器

通过该观测器估计系统总扰动并进行扰动补偿

并证明观测器收敛性。基于特征建模的方法

通过实验数据和梯度下降法对特征参数进行辨识

并基于参数值设计全系数自适应控制律

将该控制律结合线性扩张状态观测器设计一种控制策略

对系统进行精确控制。实验结果表明

新的控制策略使系统在变负载扰动工况下的定位精度达到0.003°

正弦信号跟踪误差保持在0.92°以内

系统具有较强的鲁棒性和控制精度。

Abstract

A control strategy combining the linear extended state observer and full coefficient adaptive control based on characteristic model is proposed for the time-varying load and model uncertainties of industrial robot joint servomechanism. A two-inertia flexible joint dynamics model is established

and the equation of the fifth-order extended state of joint servomechanism was obtained. A fifth-order linear extended state observer is designed based on the model

through which the total disturbance of the system is estimated and compensated

and the convergence of the observer is proved. Based on the method of characteristic modeling

the characteristic parameters are identified by experimental data and gradient descent method

and the full coefficient adaptive control law is designed based on the parameter values. A control strategy is designed to accurately control the system by combining the control law with the linear extended state observer. The experimental results show that the proposed control strategy is used to make the positioning accuracy of the system reach 0.003° under the condition of variable load disturbance and the sinusoidal signal tracking error keep within 0.92°. The system has strong robustness and control accuracy.

关键词

Keywords

references

牟方厉 , 吴丹 , 董云飞 . 具有多层感知器力矩补偿的机器人自抗扰控制 [J ] . 控制理论与应用 , 2020 , 37 ( 6 ): 1397 - 1405 .

MOU F L , WU D , DONG Y F . Active disturbance rejection control with multilayer perceptron compensating network for robot systems [J ] . Control Theory and Applications , 2020 , 37 ( 6 ): 1397 - 1405 . (in Chinese)

王立新 , 赵丁选 , 刘福才 , 等 . 电液比例伺服力加载自抗扰控制 [J ] . 机械工程学报 , 2020 , 56 ( 18 ): 216 - 225 . DOI: 10.3901/JME.2020.18.216 http://doi.org/10.3901/JME.2020.18.216 针对电液比例加载系统中力控制精度较低这一问题，提出一种由死区逆补偿与线性自抗扰器构成的串联控制器。所设计的串联控制器充分考虑了比例阀死区非线性、液压参数摄动、外部未知扰动等因素。首先，在分析电液比例力加载系统模型机理基础上，根据系统相对阶次，设计二阶线性自抗扰控制器，通过扩张状态观测器对系统"总扰动"进行实时估计，并采用线性误差反馈控制律给予主动补偿。此外，为解决比例阀死区引起的系统响应滞后与稳态误差过大等问题，建立光滑死区逆模型，以消除死区带来的不利影响。大量对比试验表明，提出的串联控制器有效地改善了系统动静特性，可达到更高的力控制精度，具有较强的鲁棒性和抗干扰性，为工程应用提供了参考。

WANG L X , ZHAO D X , LIU F C , et al . Active disturbance rejection control for electro-hydraulic proportional servo force loading [J ] . Journal of Mechanical Engineering: 2020 , 56 ( 18 ): 216 - 225 . (in Chinese)

徐驰 , 赵希梅 . 永磁直线同步电动机智能递归非奇异终端滑模控制 [J ] . 控制理论与应用 , 2022 , 39 ( 7 ): 1242 - 1250 .

XU C , ZHAO X M . Intelligent recursive nonsingular terminal sliding mode control of permanent magnet linear synchronous motor [J ] . Control Theory & Applications , 2022 , 39 ( 7 ): 1242 - 1250 . (in Chinese)

聂守成 , 钱林方 , 陈志群 , 等 . 基于干扰观测器的弹丸协调器电液伺服系统自适应滑模控制 [J ] . 兵工学报 , 2020 , 41 ( 9 ): 1745 - 1751 . DOI: 10.3969/j.issn.1000-1093.2020.09.006 http://doi.org/10.3969/j.issn.1000-1093.2020.09.006 针对弹丸协调器电液伺服系统中存在非匹配不确定性和参数不确定性问题，提出一种基于干扰观测器的自适应滑模控制策略。采用干扰观测器估计系统中的非匹配不确定性，通过Lyapunov稳定性理论证明干扰观测器的稳定性，并将其引入新型积分滑模切换函数的设计中，使控制器能够对非匹配不确定性提供有效补偿，提高控制精度。为了降低系统参数不确定性的影响，在滑模控制器设计中引入自适应律以保证控制器的动态性能，并对控制器的全局稳定性进行了证明。实验结果表明：采用的干扰观测器和自适应律能够准确描述系统特性；基于干扰观测器的自适应滑模控制器能够满足期望轨迹的跟踪要求，使设计的控制器在不同工况下均具有较好的动态跟踪特性和稳态精度，并具有较强的鲁棒性。

NIE S C , QIAN L F , CHEN Z Q , et al . Adaptive sliding mode control based on disturbance observer for bullets coordinator electro-hydraulic servo system [J ] . Acta Armamentarii , 2020 , 41 ( 9 ): 1745 - 1751 . (in Chinese)

苗双全 , 张宝泉 , 王明超 , 等 . 基于扰动观测器的机载光电稳定平台自适应指数时变滑模控制 [J ] . 兵工学报 , 2022 , 43 ( 7 ): 1636 - 1645 . DOI: 10.12382/bgxb.2021.0229 http://doi.org/10.12382/bgxb.2021.0229 针对考虑载机干扰、摩擦力矩和参数不确定性等扰动因素影响的机载光电稳定平台高精度控制问题，提出了一种基于非线性扰动观测器的自适应指数时变滑模控制方法。该方法利用非线性扰动观测器观测系统的聚合不确定性，用来抵消外界扰动和参数不确定性对系统的干扰。在此基础上，设计自适应指数时变滑模控制器，实现了光电稳定平台伺服系统在残余聚合扰动影响下的期望角位置转动的全局鲁棒控制，该方法不需要确定聚合不确定性的上界信息，同时避免了普通自适应滑模的切换增益过度自适应问题，最终通过李雅普诺夫稳定性定理证明了闭环系统的全局渐近稳定性，系统角位置最终渐近收敛到期望角位置。数值仿真和样机测试结果表明，在外界扰动和参数不确定性的影响下，该方法能够实现系统的高精度角位置控制。

MIAO S Q , ZHANG B Q , WANG M C , et al . Adaptive exponential time-varying sliding mode control based on disturbance observer for photoelectric stabilized airborne platform [J ] . Acta Armamentarii , 2022 , 43 ( 7 ): 1636 - 1645 . (in Chinese)

丁力 , 姚勇 , 巢渊 , 等 . 面向水质采样的绳驱动空中机械臂抗干扰控制 [J ] . 农业机械学报 , 2022 , 53 ( 8 ): 452 - 458 .

DING L , YAO Y , CHAO Y , et al . Disturbance rejection control for cable-driven aerial manipulator applied on water samples [J ] . Transactions of the Chinese Society for Agricultural Machinery , 2022 , 53 ( 8 ): 452 - 458 . (in Chinese)

王会明 , 张扬 , 王雪闯 . 移动机器人的线性自抗扰控制设计与实验验证 [J ] . 控制理论与应用 , 2022 , 39 ( 7 ): 1289 - 1296 .

WANG H M , ZHANG Y , WANG X C . Design and implementation of linear active disturbance rejection control for mobile robots [J ] . Control Theory & Applications , 2022 , 39 ( 7 ): 1289 - 1296 . (in Chinese)

于欣波 , 贺威 , 薛程谦 , 等 . 基于扰动观测器的机器人自适应神经网络跟踪控制研究 [J ] . 自动化学报 , 2019 , 45 ( 7 ): 1307 - 1324 .

YU X B , HE W , XUE C Q , et al . Disturbance observer-based adaptive neural network tracking control for robots [J ] . Acta Automatica Sinica , 2019 , 45 ( 7 ): 1307 - 1324 . (in Chinese)

WU H X , HU J , XIE Y C . Characteristic model-based all-coefficient adaptive control method and its applications [J ] . IEEE Transactions on Systems, Man, and Cybernetics , 2007 , 37 ( 2 ): 213 - 221 .

吴宏鑫 , 胡军 , 解永春 . 基于特征模型的智能自适应控制 [M ] . 北京 : 中国科学技术出版社 , 2009 .

WU H X , HU J , XIE Y C . Characteristic model-based intelligent adaptive control [M ] . Beijing : Science and Technology Press of China , 2009 . (in Chinese)

孟斌 , 唐青原 , 吴宏鑫 . 特征模型理论及其在火星气动捕获制导中的应用 [J ] . 中国科学:技术科学 , 2020 , 50 ( 5 ): 483 - 492 .

MENG B , TANG Q Y , WU H X . Characteristic model and its applications in mars aerocapture guidance [J ] . Scientia Sinica Technologica , 2020 , 50 ( 5 ): 483 - 492 . (in Chinese) DOI: 10.1360/SST-2019-0304 http://doi.org/10.1360/SST-2019-0304 http://engine.scichina.com/doi/10.1360/SST-2019-0304 http://engine.scichina.com/doi/10.1360/SST-2019-0304

李超 , 何英姿 , 胡勇 . 基于特征模型的挠性航天器接触消旋控制 [J ] . 空间控制技术与应用 , 2022 , 48 ( 2 ): 54 - 61 .

LI C , HE Y Z , HU Y . Characteristic model-based contact racemization control for flexible spacecraft [J ] . Aerospace Control and Application , 2022 , 48 ( 2 ): 54 - 61 . (in Chinese)

张世俊 , 邢琰 . 参数不确定机器人关节特征建模与自适应控制研究 [J ] . 载人航天 , 2019 , 25 ( 5 ): 625 - 630 .

ZHANG S J , XING Y . Research on joint characteristics modeling and adaptive control of robot with uncertain parameters [J ] . Manned Spaceflight , 2019 , 25 ( 5 ): 625 - 630 . (in Chinese)

高熠 , 吴益飞 , 关妍 . 基于特征模型的双电机伺服系统2阶离散滑模控制 [J ] . 机械设计与制造工程 , 2020 , 49 ( 3 ): 29 - 34 .

GAO Y , WU Y F , GUAN Y . Second-order discrete sliding mode control of the double-motor servo system based on feature model [J ] . Machine Design and Manufacturing Engineering , 2020 , 49 ( 3 ): 29 - 34 . (in Chinese)

王翔 , 吴益飞 , 高阳 , 等 . 基于扩展状态观测器的伺服系统特征建模和自适应滑模控制 [J ] . 南京理工大学学报(自然科学版) , 2019 , 43 ( 3 ): 261 - 268 ,274.

WANG X , WU Y F , GAO Y , et al . Extended state observer-based characteristic modeling and adaptive sliding-mode control for servo system [J ] . Journal of Nanjing University of Science and Technology , 2019 , 43 ( 3 ): 261 - 268 , 274. (in Chinese)

HUANG Y , XUE W C . Active disturbance rejection control: methodology and theoretical analysis [J ] . ISA Transactions , 2014 , 53 ( 4 ): 963 - 976 . DOI: 10.1016/j.isatra.2014.03.003 http://doi.org/10.1016/j.isatra.2014.03.003 The methodology of ADRC and the progress of its theoretical analysis are reviewed in the paper. Several breakthroughs for control of nonlinear uncertain systems, made possible by ADRC, are discussed. The key in employing ADRC, which is to accurately determine the "total disturbance" that affects the output of the system, is illuminated. The latest results in theoretical analysis of the ADRC-based control systems are introduced. Copyright © 2014 ISA. Published by Elsevier Ltd. All rights reserved.

ZHANG H , ZHAO S , GAO Z . An active disturbance rejection control solution for the two-mass-spring benchmark problem [C ] // Proceedings of the American Control Conference.Boston,MA,US:IEEE , 2016 : 1566 - 1571 .

ISKANDAR M , OTT C , EIBERGER O , et al . Joint-level control of the DLR lightweight robot SARA [C ] // Proceedings of 2020 IEEE/RSJ International Conference on Intelligent Robots and Systems. Piscataway,NJ , US : IEEE , 2020 : 8903 - 8910 .

ZUO Z Y , JU X L , DING Z T . Control of gear transmission servo systems with asymmetric deadzone nonlinearity [J ] . IEEE Transactions on Control Systems Technology , 2016 , 24 ( 4 ): 1472 - 1479 . DOI: 10.1109/TCST.2015.2493119 http://doi.org/10.1109/TCST.2015.2493119 http://ieeexplore.ieee.org/document/7314878/ http://ieeexplore.ieee.org/document/7314878/

吴宏鑫 , 王颖 , 解永春 . 非线性系统的特征建模与控制方法 [J ] . 控制工程 , 2002 ( 6 ): 1 - 7 .

WU H X , WANG Y , XIE Y C . Characteristic modeling and control method of nonlinear system [J ] . Control Engineering , 2002 ( 6 ): 1 - 7 . (in Chinese)

浏览量

204

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

行进间无人车载炮稳定系统自抗扰自适应复合控制

Increasing analyzable steel thickness for thin layer activation experiments

Complex structure of human Hsp90^N and a novel small inhibitor FS5

Optimization of the S-band side-coupled cavities for proton acceleration

Multi-frequency point supported LLRF front-end for CiADS wide-bandwidth application