含不凝气体的蒸汽凝结换热数值研究

郭庆; 罗凯; 耿少航; 秦侃

doi:10.12382/bgxb.2022.0225

您当前的位置：

首页 >

文章列表页 >

含不凝气体的蒸汽凝结换热数值研究

更新时间：2025-08-18

- 含不凝气体的蒸汽凝结换热数值研究
- Numerical Study of Condensation Heat Transfer of Steam with Non-condensable Gas
- 兵工学报 2023年44卷第7期页码：2080-2091
- 作者机构：
  
  1. 西北工业大学航海学院, 陕西西安 710072
  2. 西安电子工程研究所, 陕西西安 710100
- 作者简介：
  
  *邮箱: kan.qin@nwpu.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51805435)
- DOI：10.12382/bgxb.2022.0225
  中图分类号：
- 收稿：2022-04-02，
  
  网络出版：2023-08-07，
  
  纸质出版：2023-07-30
- 稿件说明：
移动端阅览
郭庆, 罗凯, 耿少航, 等. 含不凝气体的蒸汽凝结换热数值研究[J]. 兵工学报, 2023,44(7):2080-2091.

Qing GUO, Kai LUO, Shaohang GENG, et al. Numerical Study of Condensation Heat Transfer of Steam with Non-condensable Gas[J]. Acta Armamentarii, 2023, 44(7): 2080-2091.
郭庆, 罗凯, 耿少航, 等. 含不凝气体的蒸汽凝结换热数值研究[J]. 兵工学报, 2023,44(7):2080-2091. DOI： 10.12382/bgxb.2022.0225.

Qing GUO, Kai LUO, Shaohang GENG, et al. Numerical Study of Condensation Heat Transfer of Steam with Non-condensable Gas[J]. Acta Armamentarii, 2023, 44(7): 2080-2091. DOI： 10.12382/bgxb.2022.0225.

摘要

为研究水下半闭式循环动力系统中高压换热器的性能

建立适用于高压下含大比例不凝气体的蒸汽凝结过程的数值模型

并考虑重力对水平套管式换热器的燃气流道进行多工况仿真计算与试验验证。研究结果表明:由于重力的存在

管道顶部和底部的液膜厚度不均匀

同时管内气相工质会产生二次旋流

两种作用将导致管内换热的不均匀特性;管径的减小将使管内工质流速增加

增大雷诺数的同时也使底部液膜变薄

有助于增强换热;流速增加削弱了重力的影响

使管道顶部和底部换热强度的差距变小;在所设工况下

即使考虑总换热面积的缩减

减小管径仍有助于总换热功率的提升;试验与仿真的管内温度最大误差为19.5%。所得成果可为水下半闭式循环动力系统高压换热器的设计提供参考。

Abstract

In order to study the performance of a high-pressure heat exchanger in an underwater semi-closed cycle power system

we establish a numerical model to analyze the condensation process of steam containing a significant proportion of non-condensable gas under high pressure. The model is verified through a specific experiment

and we conduct simulations of the gas flow channel in the heat exchanger under different working conditions

taking gravity into consideration. The results show that due to the gravity

the liquid film thicknesses at the top and bottom of the pipe are not uniform

resulting in swirling flow within the gas phase. These two effects lead to uneven heat transfer characteristics in the pipe. Additionally

the flow velocity increases with the decreasing pipe diameter

causing a rise in the Reynolds number and a thinning of the bottom liquid film. This contributes to heat transfer. The increased flow velocity also reduces the effect of gravity

reducing the disparity in heat transfer intensity between the top and bottom sections of the pipe. Under the working conditions in this paper

even with a reduced total heat transfer area

reducing the pipe diameter remains conducive to the improvement of the total heat transfer power. The maximum temperature error between the experimental and simulated results is 19.5%. The conclusions contribute to the design of high-pressure heat exchangers in underwater semi-closed cycle power systems.

关键词

Keywords

references

钟宏伟 , 李国良 , 宋林桦 , 等 . 国外大型无人水下航行器发展综述 [J ] . 水下无人系统学报 , 2018 , 26 ( 4 ): 273 - 282 .

ZHONG H W , LI G L , SONG L H , et al . Development of large displacement unmanned undersea vehicle in foreign countries: a review [J ] . Journal of Unmanned Undersea Systems , 2018 , 26 ( 4 ): 273 - 282 . (in Chinese)

任丽彬 , 桑林 , 赵青 , 等 . AUV动力电池应用现状及发展趋势 [J ] . 电源技术 , 2017 , 41 ( 6 ): 952 - 955 .

REN L B , SANG L , ZHAO Q , et al . Application status and development trend of power battery for AUV [J ] . Chinese Journal of Power Sources , 2017 , 41 ( 6 ): 952 - 955 . (in Chinese)

KIELY D . Review of underwater thermal propulsion [C ] //Proceedings of the 30th Joint Propulsion Conference and Exhibit. Indianapolis,IN , US : AIAA , 1994 .

白杰 , 党建军 , 罗凯 , 等 . 水下航行器闭式循环动力系统动态仿真 [J ] . 鱼雷技术 , 2016 , 24 ( 6 ): 438 - 443 .

BAI J , DANG J J , LUO K , et al . Dynamic simulation of closed cycle power system for UUV [J ] . Torpedo Technology , 2016 , 24 ( 6 ): 438 - 443 . (in Chinese)

HILLS R . HAP/OTTO fuel application to torpedo engines [C ] // Proceedings of the 18th Joint Propulsion Conference. Cleveland,OH,US:AIAA , 1982 .

KUHN S Z , SCHROCK V E , PETERSON P F . An investigation of condensation from steam-gas mixtures flowing downward inside a vertical tube [J ] . Nuclear Engineering and Design , 1997 , 177 ( 1/2/3 ): 53 - 69 . DOI: 10.1016/S0029-5493(97)00185-4 http://doi.org/10.1016/S0029-5493(97)00185-4 https://linkinghub.elsevier.com/retrieve/pii/S0029549397001854 https://linkinghub.elsevier.com/retrieve/pii/S0029549397001854

KUHN S Z . Investigation of heat transfer from condensing steam-gas mixtures and turbulent films flowing downward inside a vertical tube [D ] . Berkeley,CA,US : University of California , 1995 .

LEE K , KIM M H . Experimental and empirical study of steam condensation heat transfer with a noncondensable gas in a small-diameter vertical tube [J ] . Nuclear Engineering and Design , 2008 , 238 ( 1 ): 207 - 216 . DOI: 10.1016/j.nucengdes.2007.07.001 http://doi.org/10.1016/j.nucengdes.2007.07.001 https://linkinghub.elsevier.com/retrieve/pii/S0029549307004256 https://linkinghub.elsevier.com/retrieve/pii/S0029549307004256

REN B , ZHANG L , CAO J , et al . Experimental and theoretical investigation on condensation inside a horizontal tube with non-condensable gas [J ] . International Journal of Heat and Mass Transfer , 2015 , 82 : 588 - 603 . DOI: 10.1016/j.ijheatmasstransfer.2014.11.041 http://doi.org/10.1016/j.ijheatmasstransfer.2014.11.041 https://linkinghub.elsevier.com/retrieve/pii/S0017931014010138 https://linkinghub.elsevier.com/retrieve/pii/S0017931014010138

马喜振 . 高压下非凝性气体对蒸汽冷凝传热特性影响研究 [D ] . 北京 : 清华大学 , 2017 .

MA X Z . Research on steam condensation with non-condensable gases under the high pressure [D ] . Beijing : Tsinghua University , 2017 . (in Chinese)

PARK S K , KIM M H , YOO K J . Effects of a wavy interface on steam-air condensation on a vertical surface [J ] . International Journal of Multiphase Flow , 1997 , 23 ( 6 ): 1031 - 1042 . DOI: 10.1016/S0301-9322(97)00022-0 http://doi.org/10.1016/S0301-9322(97)00022-0 https://linkinghub.elsevier.com/retrieve/pii/S0301932297000220 https://linkinghub.elsevier.com/retrieve/pii/S0301932297000220

JI D , LEE J , KIM D , et al . Effective reduction of non-condensable gas effects on condensation heat transfer: surface modification and steam jet injection [J ] . Applied Thermal Engineering , 2020 , 174 : 115264 . DOI: 10.1016/j.applthermaleng.2020.115264 http://doi.org/10.1016/j.applthermaleng.2020.115264 https://linkinghub.elsevier.com/retrieve/pii/S135943111937629X https://linkinghub.elsevier.com/retrieve/pii/S135943111937629X

FU W , LI X W , WU X X , et al . Numerical investigation of convective condensation with the presence of non-condensable gases in a vertical tube [J ] . Nuclear Engineering and Design , 2016 , 297 : 197 - 207 . DOI: 10.1016/j.nucengdes.2015.11.034 http://doi.org/10.1016/j.nucengdes.2015.11.034 https://linkinghub.elsevier.com/retrieve/pii/S0029549315005683 https://linkinghub.elsevier.com/retrieve/pii/S0029549315005683

ALSHEHRI A , ANDALIB S , KAVEHPOUR H P . Numerical modeling of vapor condensation over a wide range of non-condensable gas concentrations [J ] . International Journal of Heat and Mass Transfer , 2020 , 151 ( 119405 ).

GROFF M K , ORMISTON S J , SOLIMAN H M . Numerical solution of film condensation from turbulent flow of vapor-gas mixtures in vertical tubes [J ] . International Journal of Heat and Mass Transfer , 2007 , 50 ( 19/20 ): 3899 - 3912 . DOI: 10.1016/j.ijheatmasstransfer.2007.02.012 http://doi.org/10.1016/j.ijheatmasstransfer.2007.02.012 https://linkinghub.elsevier.com/retrieve/pii/S0017931007001585 https://linkinghub.elsevier.com/retrieve/pii/S0017931007001585

BIAN H Z , SUN Z N , CHENG X , et al . CFD evaluations on bundle effects for steam condensation in the presence of air under natural convection conditions [J ] . International Communications in Heat and Mass Transfer , 2018 , 98 : 200 - 208 . DOI: 10.1016/j.icheatmasstransfer.2018.09.003 http://doi.org/10.1016/j.icheatmasstransfer.2018.09.003 https://linkinghub.elsevier.com/retrieve/pii/S0735193318302227 https://linkinghub.elsevier.com/retrieve/pii/S0735193318302227

ZSCHAECK G , FRANK T , BURNS A D . CFD modelling and validation of wall condensation in the presence of non-condensable gases [J ] . Nuclear Engineering and Design , 2014 , 279 ( SI ): 137 - 146 . DOI: 10.1016/j.nucengdes.2014.03.007 http://doi.org/10.1016/j.nucengdes.2014.03.007 https://linkinghub.elsevier.com/retrieve/pii/S0029549314001393 https://linkinghub.elsevier.com/retrieve/pii/S0029549314001393

顾成勇 . 含不凝气的竖直管内蒸汽冷凝数值模拟研究 [D ] . 大连 : 大连理工大学 , 2016 .

GU C Y . Numerical simulation on condensation in presence of non-condensable gas in vertical tubes [D ] . Dalian : Dalian University of Technology , 2016 . (in Chinese)

耿少航 , 党建军 , 赵佳 , 等 . 高压下含大比例不凝气体的水蒸气对流冷凝数值仿真 [J ] . 水下无人系统学报 , 2021 , 29 ( 1 ): 88 - 96 .

GENG S H , DANG J J , ZHAO J , et al . Numerical simulation of convective condensation of steam with large proportion of non-condensable gas under high pressure [J ] . Journal of Unmanned Undersea Systems , 2021 , 29 ( 1 ): 88 - 96 . (in Chinese)

HUANG J , ZHANG J X , WANG L . Review of vapor condensation heat and mass transfer in the presence of non-condensable gas [J ] . Applied Thermal Engineering , 2015 , 89 ( 5 ): 469 - 484 . DOI: 10.1016/j.applthermaleng.2015.06.040 http://doi.org/10.1016/j.applthermaleng.2015.06.040 https://linkinghub.elsevier.com/retrieve/pii/S1359431115005943 https://linkinghub.elsevier.com/retrieve/pii/S1359431115005943

ANSYS . Ansys help [M ] . Canonsburg,PA,US : Ansys Inc. , 2016 .

KHARANGATE C R , MUDAWAR I . Review of computational studies on boiling and condensation [J ] . International Journal of Heat and Mass Transfer , 2017 , 108(A) : 1164 - 1196 .

TANG Y , ZHU S L , QIU L M . Determination of mass transfer coefficient for condensation simulation [J ] . International Journal of Heat and Mass Transfer , 2019 , 143 (Nov.) : 118481 - 118485 .

MENTER F R . 2-Equation eddy-viscosity turbulence models for engineering applications [J ] . AIAA Journal , 1994 , 32 ( 8 ): 1598 - 1605 . DOI: 10.2514/3.12149 http://doi.org/10.2514/3.12149 https://arc.aiaa.org/doi/10.2514/3.12149 https://arc.aiaa.org/doi/10.2514/3.12149

李宗吉 , 王树宗 , 陈华东 , 等 . 奥托-Ⅱ单组元推进剂燃烧产物平衡组成计算模型及仿真结果 [J ] . 舰船科学技术 , 2004 , 26 ( 5 ): 27 - 30 .

LI Z J , WANG S Z , CHEN H D , et al . Mathematical model and simulation results of equilibrium compositions of OTTO-Ⅱ monopropellant’s combustion products [J ] . Ship Science and Technology , 2004 , 26 ( 5 ): 27 - 30 . (in Chinese)

李晓莹 . 传感器与测试技术 [M ] . 北京 : 高等教育出版社 , 2019 .

LI X Y . Sensors and test technology [M ] . Beijing : Higher Education Press , 2019 . (in Chinese)

浏览量

399

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

浅水效应对水陆两栖车辆水动力性能影响

摩擦焊柱塞的多体动力学特性及其对泵空化的改善

高压气体发射装置内弹道特性及膛口流场分析

涡环旋转伞充气过程及气动特性分析

基于计算流体力学与质点弹道耦合的底部排气弹工作过程以及射程预示