Driving Stability Control for Corner Module Architecture Special Vehicle to Escape from Pit

ZHAO Minghui; ZHENG Haoyuan; LIU Shuaishuai; MA Haoran; YAO Shuangji; ZHANG Lipeng

doi:10.12382/bgxb.2025.0574

您当前的位置：

首页 >

文章列表页 >

Driving Stability Control for Corner Module Architecture Special Vehicle to Escape from Pit

更新时间：2026-05-06

- Driving Stability Control for Corner Module Architecture Special Vehicle to Escape from Pit
- Acta Armamentarii Vol. 47, Issue 4, Pages: 250574(2026)
- 作者机构：
  
  燕山大学河北省特种运载装备重点实验室，河北秦皇岛 066004
  燕山大学车辆与能源学院，河北秦皇岛 066004
- 作者简介：
- 基金信息：
- DOI：10.12382/bgxb.2025.0574
  CLC： U461.6
- Received：30 June 2025，
  
  Online First：25 December 2025，
  
  Published：2026-04
- 稿件说明：
移动端阅览
ZHAO Minghui, ZHENG Haoyuan, LIU Shuaishuai, et al. Driving Stability Control for Corner Module Architecture Special Vehicle to Escape from Pit[J]. Acta Armamentarii, 2026, 47(4): 250574.
DOI：

ZHAO Minghui, ZHENG Haoyuan, LIU Shuaishuai, et al. Driving Stability Control for Corner Module Architecture Special Vehicle to Escape from Pit[J]. Acta Armamentarii, 2026, 47(4): 250574. DOI： 10.12382/bgxb.2025.0574.

摘要

角模块架构特种车辆具有更好的动力学控制性能，为提升其在陷坑时的脱困和稳定性控制能力，提出一种运动姿态协调控制方法。设计前轮出坑流程，根据轮胎与地面力学的分析，构建车身姿态与质心位置关系模型和各轮垂向载荷模型，并揭示出坑高度与坑底路面附着系数和载荷系数的关系；建立整车14自由度动力学模型，设计车高调节前馈控制器和高复杂度线性二次型高斯稳定性反馈控制器；通过角模块样机试验验证滚珠丝杠悬架模型的准确性，并搭建硬件在环测试平台，与低复杂度线性二次型高斯控制器进行对比。研究结果表明，在坑深为0.3m工况下，所设计控制器控制效果明显提升，左右两前轮依次出坑过程中，峰值载荷最大的车轮，其载荷峰值分别减小15%和9%，车身俯仰角、侧倾角和车身垂向速度的最大值分别减小58%、42%和33%，为特种车辆安全脱困提供了理论依据。

Abstract

A special vehicle with corner module architecture has superior dynamic control performance. To enhance the capabilities of escape from pit and stability control of the special vehicle when trapped in a pit

a coordinated motion attitude control method is proposed. The process of front-wheels going out of pit is designed. A model of the relationship between vehicle body attitude and center of gravity position as well as a vertical load model for each wheel are established based on the analysis of tire-ground mechanics. The relationship among the height of escape from pit

the road adhesion coefficient at pit bottom and the loading coefficient is revealed. A 14-degrees-of-freedom vehicle dynamics model is established

and a feedforward controller for vehicle height adjustment and a high-complexity linear quadratic Gaussian stability feedback controller are designed. The accuracy of the ball screw suspension model is verified through the corner module prototype test

and a hardware-in-the-loop test platform is built to compare with the low-complexity linear quadratic Gaussian controller. The research results indicate that the control performance of the proposed controller is significantly improved under the condition of a pit depth of 0.3 m. When the left and right front wheels go out of the pit in sequence

the load peak of the wheel with the maximum peak load decreases by 15% and 9%

respectively

and the maximum values of the vehicle's pitch angle

roll angle and vertical velocity are reduced by 58%

42% and 33%

respectively. This provides a theoretical basis for the special vehicles escaping from pit safely.

关键词

Keywords

references

王亮，汪首坤，牛天伟，等.基于地形特征时频变换的无人特种车辆速度自适应控制方法[J].兵工学报，2024，45（10）：3718-3731.

WANG L, WANG S K, NIU T W, et al. Speed control method for unmanned special vehicle based on terrain feature time-frequency transform [J]. Acta Armamentarii, 2024, 45 (10): 3718-3731. (in Chinese)

柴凤，于雁磊，裴宇龙.电传动车辆永磁轮毂电机技术现状及展望[J].兵工学报，2021，42（10）：2060-2074.

CHAI F, YU Y L, PEI Y L.State-of-the-art technology and prospects of permanent magnet in-wheel motors for electric drive vehicles [J]. Acta Armamentarii, 2021, 42 (10): 2060-2074. (in Chinese)

张雷，徐同良，李嗣阳，等.全线控分布式驱动电动汽车底盘协同控制研究综述[J].机械工程学报，2023，59（20）：261-280.

ZHANG L, XU T L, LI S Y, et al. Overview on chassis coordinated control for full X-by-wire distributed drive electric vehicles [J]. Journal of Mechanical Engineering, 2023, 59 (20): 261-280. (in Chinese)

潘博，李胜飞，汪洋，等.多轴分布式驱动无人车辆极限操纵状态整车集成控制方法[J].兵工学报，2023，44（11）：3279-3294.

PAN B, LI S F, WANG Y, et al. Integrated control method of multiaxle distributed driving unmanned ground vehicle in handling limit [J]. Acta Armamentarii, 2023, 44 (11): 3279 - 3294. (in Chinese)

赵轩，王姝，马建，等.分布式驱动电动汽车底盘集成控制技术综述[J].中国公路学报，2023，36（4）：221-248.

ZHAO X, WANG S, MA J, et al. Review of chassis integrated control technology for distributed drive electric vehicles [J]. China Journal of Highway and Transport, 2023, 36 (4): 221-248. (in Chinese)

ZHAO R C, XIE H F, GONG X L, et al. Neural network-based adaptive height tracking control of active air suspension system with magnetorheological fluid damper subject to uncertain mass and input delay [J]. Sensors, 2024, 24 (1): 156.

YAO J L, CAI C, WANG S, et al. Hybrid model predictive control on lifting and dropping vehicle body via asymmetric damping adjustment [J]. Vehicle System Dynamics, 2023, 61 (12): 3225-3243.

张聪，刘爽，赵丁选，等.多作动器协同的特种车辆主动悬架控制方法[J].机械工程学报，2025，61（8）：228-239.

ZHANG C, LIU S, ZHAO D X, et al. Multi-actuator cooperation empowered active suspension control method for special vehicles [J]. Journal of Mechanical Engineering, 2025, 61 (8): 228-239. (in Chinese)

ZENG Q, ZHAO J. Adaptive switching control of active suspension systems:a switched system point of view [J]. IEEE Transactions on Control Systems Technology, 2024, 32 (2): 663-671.

THEUNISSEN J, SORNIOTTI A, GRUBER P, et al. Regionless explicit model predictive control of active suspension systems with preview [J]. IEEE Transactions on Industrial Electronics, 2020, 67 (6): 4877-4888.

KALE A, ÇAČLAR BAŞLAMIŞLI S. Mobility improvement of wheeled military vehicles using preview controlled active ride height system [J]. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 2023, 237 (1): 126-144.

魏道高，宋军伟，瞿文明，等.考虑轮胎弹性的重型货车越障性能研究[J].汽车工程，2019，41（1）：75-79.

WEI D G, SONG J W, QU W M, et al. A study of the obstacle surmounting performance of heavy truck considering the tire elasticity [J]. Automotive Engineering, 2019, 41 (1): 75-79. (in Chinese)

HAO W H, XU X J, XU H J, et al. Enhancing the obstacle crossing performance of all-terrain vehicle based on variablewheelbase chassis[C]∥Proceedings of IEEE/ASME International Conference on Advanced Intelligent Mechatronics. Hong Kong, China:IEEE, 2019:1329-1334.

曹洪涛，申彦，潘冬，等.祝融号火星车前进越障性能试验与分析[J].机械工程学报，2023，59（18）：294-303.

CAO H T, SHEN Y, PAN D, et al. Test and analysis on the obstacle-climbing performance of Zhu Rong rover [J]. Journal of Mechanical Engineering, 2023, 59 (18): 294-303. (in Chinese)

LIU S S, ZHANG L P, WANG J T, et al. Chassis coordinated control of corner module architecture intelligent electric vehicles for escaping from pothole on low-adhesion roads [J]. Automotive Innovation, 2025, 8:963-983.

王耀樟.角模块架构电动轮驱动汽车悬架系统优化设计及功能验证[D].秦皇岛：燕山大学，2024.

WANG Y Z.Optimized design and functional verification of the corner module architecture electric wheel drive vehicle suspension system [D]. Qinhuangdao: Yanshan University, 2024. (in Chinese)

LIU S S, ZHANG L P, LIU Y F, et al. Motion posture control of corner module architecture intelligent electric vehicle on deeppotholed roads [J]. IEEE/ASME Transactions on Mechatronics, 2024, 29 (6): 4480-4491.

ZHANG L P, LI L, QI B N. Rollover prevention control for a four in-wheel motors drive electric vehicle on an uneven road [J]. Science China Technological Sciences, 2018, 61 (6): 934-948.

MISHRA P, BANERJEE A, GHOSH M. FPGA-based real-time implementation of quadral-duty digital-PWM-controlled permanent magnet BLDC drive [J]. IEEE/ASME Transactions on Mechatronics, 2020, 25 (3): 1456-1467.

DE VIAENE J, CEULEMANS D, DERAMMELAERE S, et al. Sensorless load angle control for energy optimal sinusoidal driven BLDC motor applications [J]. IEEE/ASME Transactions on Mechatronics, 2022, 27 (4): 2290-2300.

方家帅.电动轮驱动无人驾驶车辆非结构路面辨识及车身姿态控制[D].秦皇岛：燕山大学，2023.

FANG J S.Unstructured road surface identification and body attitude control of electric wheel drive unmanned vehicle [D]. Qinhuangdao: Yanshan University, 2023. (in Chinese)

Views

下载量

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

High-confidence Minimum Acquisition Mileage of Durability Load Spectrum of Off-road Special Vehicles

Compilation of Multiaxial Load Spectra for Fatigue Durability of Special Vehicle Based on Extreme Value Extrapolation

Dynamic Characteristics of Quasi-Zero Stiffness Vibration Isolation System with Magnetic Rings

Driving Leveling Control Method with Multi-Actuator Cooperation for Special Vehicles

Related Author

MA Haoran

ZHANG Lipeng

YAO Shuangji

LIU Shuaishuai

ZHENG Haoyuan

ZHAO Minghui

Yinqing WAN

Guofeng ZHENG

Related Institution

School of Mechatronics and Vehicle Engineering, Chongqing Jiaotong University

China Automotive Engineering Research Institute Co., Ltd.

School of Mechanical Engineering, Taiyuan University of Science and Technology

School of Mechanical and Aerospace Engineering, Jilin University

School of Electrical Engineering, Yanshan University

Postal code：100089
Tel：010-68963060/68962718 Fax：010-68963025 Email：bgxb@cos.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备05059581号-4 京公网安备11010802024360号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
Total Visits：128316 Visits Today：432

⁰