Analysis of Petri Net Model and Index Demonstration for Torpedo Equipment Testing and Maintenance

Ning ZHANG; Haihua LIN; Yaping SUN; Zongji LI; Shizhe WANG

doi:10.12382/bgxb.2021.0768

您当前的位置：

首页 >

文章列表页 >

Analysis of Petri Net Model and Index Demonstration for Torpedo Equipment Testing and Maintenance

更新时间：2025-08-18

- Analysis of Petri Net Model and Index Demonstration for Torpedo Equipment Testing and Maintenance
- Acta Armamentarii Vol. 44, Issue 3, Pages: 886-894(2023)
- 作者机构：
  
  1. 海军工程大学兵器工程学院，湖北武汉 430000
  2. 92767部队，山东青岛 266000
- 作者简介：
- 基金信息：
- DOI：10.12382/bgxb.2021.0768
  CLC：
- Received：13 November 2021，
  
  Published：28 March 2023
- 稿件说明：
移动端阅览
Ning ZHANG, Haihua LIN, Yaping SUN, et al. Analysis of Petri Net Model and Index Demonstration for Torpedo Equipment Testing and Maintenance[J]. Acta Armamentarii, 2023, 44(3): 886-894.
DOI：

Ning ZHANG, Haihua LIN, Yaping SUN, et al. Analysis of Petri Net Model and Index Demonstration for Torpedo Equipment Testing and Maintenance[J]. Acta Armamentarii, 2023, 44(3): 886-894. DOI： 10.12382/bgxb.2021.0768.

摘要

针对鱼雷装备测试维修使用需求，采用广义随机Petri网模型对鱼雷装备进行测试维修建模，并对测试性指标进行分析。分别建立鱼雷装备系统层和结构层GSPN模型，依据故障模式影响和危害性分析(FMECA)对鱼雷装备故障模式进行分类；对鱼雷结构层GSPN模型非基本变迁进行拓展，构建鱼雷装备基层级维修子网GSPN模型；采用同构法求解维修子网GSPN模型，利用的稳态可用度解析公式分析测试性参数与使用可用度(

)之间的影响关系；以某型号鱼雷为例，开展测试性指标求解和模型仿真验证。研究结果表明，模型仿真可用度A’=0.999 8，与系统要求值误差小于1%，验证了所构建模型的可行性和有效性。

Abstract

To meet the needs of testing and maintenance of torpedo equipment

the generalized stochastic Petri net model is used to the testing and maintenance modelling of the torpedo equipment

and the testability indices are analyzed. Firstly

the GSPN models of the system layer and the structure layer of the torpedo equipment are established respectively

and the failure modes of the torpedo equipment are classified according to the failure mode

effects and criticality analysis (FMECA). Then the non-basic transition of the GSPN model of the torpedo structure layer is expanded. Second

the isomorphism method is adopted to solve the maintenance sub-network GSPN model

and the steady-state availability analytical formula is employed to analyze the influence relationship between the testability parameters and the use availability (

). Finally

taking a certain type of torpedo as an example

the testability index solution and model simulation verification are carried out. The model simulation availability is A’=0.999 8

and the e

rror with the system requirement value is less than 1%

which verifies the feasibility and effectiveness of the constructed model.

关键词

Keywords

references

李天梅 . 装备测试性验证试验优化设计与综合评估方法研究 [D ] . 长沙 : 国防科技大学 , 2010 .

LI T M . Research on optimal design and comprehensive evaluation method of equipment testability verification test [D ] . Changsha : National University of Defense Technology , 2010 . (in Chinese)

李哲 , 沈强 , 张瑾 , 等 . 电子装备层次化模型研究进展及发展趋势 [J ] . 北京石油化工学院学报 , 2020 , 28 ( 3 ): 31 - 36 .

LI Z , SHEN Q , ZHANG J , et al. Research progress and development trend of the hierarchical model of electronic equipment [J ] . Journal of Beijing Institute of Petrochemical Technology , 2020 , 28 ( 3 ): 31 - 36 . (in Chinese)

SHAKERI M . Advances in system fault modeling and diagnosis [M ] . CT , US : University of Connecticut , 1996 .

DEB S , PATTIPATI K R , RAGHAVAN V , et al. Multi-signal flow graphs:a novel approach for system testability analysis and fault diagnosis . IEEE AES Magazine , 1995 ( 5 ): 14 - 25 .

刘静 , 辛军 , 胡向顺 , 等 . 基于多信号流图模型的装备测试性分析 [J ] . 信息技术 , 2013 , 37 ( 1 ): 177 - 179 .

LIU J , XIN J , HU X S , et al. The testability analysis about equipment based on multi-signal flow graphs model [J ] . Information Technology , 2013 , 37 ( 1 ): 177 - 179 . (in Chinese)

DEB S , GHOSHAL S , MATHUR A , et al. Multisignal modeling for diagnosis, FMECA, and reliability [C ] // Proceedings of 1998 IEEE International Conference on Systems, Man, and Cybernetics (Cat. No. 98CH36218). San Diego, CA, US:IEEE , 1998 , 3 : 3026 - 3031 .

CHAN L K , LU M . Quality function deployment: a literature review [J ] . European Journal of Operational Research , 2002 , 143 : 463 - 497 . DOI: 10.1016/S0377-2217(02)00178-9 http://doi.org/10.1016/S0377-2217(02)00178-9 https://linkinghub.elsevier.com/retrieve/pii/S0377221702001789 https://linkinghub.elsevier.com/retrieve/pii/S0377221702001789

林闯 . 随机Petri网和系统性能评价 [M ] . 北京 : 清华大学出版社 , 2005 .

LIN C . Stochastic Petri nets and system performance evaluation [M ] . Beijing : Tsinghua University Press , 2005 . (in Chinese)

苏永定 . 装备系统测试性需求分析技术研究 [D ] . 长沙 : 国防科学技术大学 , 2011 .

SU Y D . Research on testability requirement analysis for equipment [D ] . Changsha : National University of Defense Technology , 2011 . (in Chinese)

LIU T S , CHIOU S B . The application of petri nets to failure analysis . Reliability Engineering and System Safety , 1997 , 57 ( 6 ): 129 - 142 . DOI: 10.1016/S0951-8320(97)00030-6 http://doi.org/10.1016/S0951-8320(97)00030-6 https://linkinghub.elsevier.com/retrieve/pii/S0951832097000306 https://linkinghub.elsevier.com/retrieve/pii/S0951832097000306

吴哲辉 . Petri 网导论 [M ] . 北京 : 机械工业出版社 , 2006 : 1 - 19 .

WU Z H . An introduction to Petri nets [M ] . Beijing : China Machine Press , 2006 : 1 - 19 . (in Chinese)

蒋宏斌 . 航空布撒武器测试性设计建模与分析方法研究 [D ] . 哈尔滨 : 哈尔滨工业大学 , 2019 .

JIANG H B . Research on modeling and analysis method of aeronautical weapon testability design [D ] . Harbin : Harbin Institute of Technology , 2019 . (in Chinese)

王瑶 . 基于Petri网的四性一体化建模及仿真方法研究 [D ] . 西安 : 西北工业大学 , 2016 .

WANG Y . A modelling and simulation method for reliability, testability, maintainability and safety analysis based on Petri nets [D ] . Xi’an : Northwestern Polytechnical University , 2016 . (in Chinese)

翟禹尧 , 史贤俊 , 韩露 , 等 . 基于层次广义随机Petri网的测试性建模新方法 [J ] . 兵工学报 , 2020 , 41 ( 1 ): 161 - 170 . DOI: 10.3969/j.issn.1000-1093.2020.01.019 http://doi.org/10.3969/j.issn.1000-1093.2020.01.019 针对目前装备系统采用层次化、模块化设计，维修级别与测试性建模复杂度大大提高的问题，提出一种基于层次广义随机Petri网（HGSPN）的测试性建模方法。将主流模型和广义随机Petri网（GSPN）模型进行对比，阐明主流模型存在的问题，以及选择GSPN模型的原因；对装备进行层次划分，建立分层GSPN模型；系统及其组成元件存在多个故障模式，为区分这些故障模式提出一套完整编码方案；给出可达性算法获取层次相关性矩阵，运用测试性评估数学模型得到各层级的测试性水平，将各层级的测试性信息汇总，得到装备完整的测试性水平。以某型导弹发动机系统为例，建立其HGSPN模型，并对测试性指标进行确定，得到100%的故障检测率和66.7%的故障隔离率，验证了所提建模方法和相应算法的有效性。

ZHAI Y Y , SHI X J , HAN L , et al. New testability modeling method based on hierarchical generalized stochastic Petri nets [J ] . Acta Armamentarii , 2020 , 41 ( 1 ): 161 - 170 . (in Chinese)

邱静 , 刘冠军 , 杨鹏 , 等 . 装备测试性建模与设计技术 [M ] . 北京 : 科学出版社 , 2012 .

QIU J , LIU G J , YANG P , et al. Equipment test modeling and design technology [M ] . Beijing : Science Press , 2012 . (in Chinese)

张钊旭 . 鱼雷测试性建模方法及应用研究 [D ] . 西安 : 中国舰船研究院 , 2018 .

ZHANG Z X . Research on testability modeling method and application for torpedo [D ] . Xi’an : China Ship Research Institute , 2018 . (in Chinese)

Views

367

下载量

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

GSPN-based Determination Method of Torpedo System Level Testability Parameters

Interior Trajectory Characteristics of Underwater Ejection Using a Flexible Piston Rod Driven by Water Pressure

Complex Load of Torpedo Near-field Explosion and Its Damage Mode to Ships

Combat Decision and Correlation Analysis of Warship Integrated Defense Torpedo

Optimal Selection of Failure Samples Based on Multiple Impact Factors and Importance

Related Author

SUN Yaping

LI Zongji

ZHANG Ning

SUN Qiang

SUN Yuchen

TANG Jianlin

Wenting WU

Yanchao DING

Related Institution

Unit 92767 of PLA

School of Weaponry Engineering, Naval University of Engineering

China Ship Scientific Research Center

Unit 91439 of PLA

Unit 92730 of PLA

Postal code：100089
Tel：010-68963060/68962718 Fax：010-68963025 Email：bgxb@cos.org.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备05059581号-4 京公网安备11010802024360号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
Total Visits：44495 Visits Today：475

⁰