舱室密闭空间中爆炸载荷燃烧增强效应试验研究

doi:10.3969/j.issn.1000-1093.2020.01.009

兵工学报 ›› 2020, Vol. 41 ›› Issue (1): 75-85.doi: 10.3969/j.issn.1000-1093.2020.01.009

舱室密闭空间中爆炸载荷燃烧增强效应试验研究

孔祥韶^1,2，况正²，郑成^1,2，吴卫国^1,2

(1.武汉理工大学绿色智能江海直达船舶与邮轮游艇研究中心，湖北武汉 430063；2.武汉理工大学交通学院船舶、海洋与结构工程系，湖北武汉 430063)

收稿日期:2019-03-01 修回日期:2019-03-01 上线日期:2020-02-22
通讯作者: 郑成(1991—)，男，讲师 E-mail:zhengchengyeep@whut.edu.cn
作者简介:孔祥韶(1983—)，男，副教授，博士生导师。E-mail: kongxs@whut.edu.cn
基金资助:
装备预先研究教育部联合基金青年人才项目(6141A02033108)

Experimental Study of Afterburning Enhancement Effect for Blast Load in Confined Compartment Space

KONG Xiangshao^1,2, KUANG Zheng², ZHENG Cheng^1,2, WU Weiguo^1,2

(1.Green & Smart River-Sea-Going Ship, Cruise and Yacht Research Center, Wuhan University of Technology, Wuhan 430063, Hubei, China; 2.Department of Naval Architecture, Ocean and Structural Engineering, School of Transportation, Wuhan University of Technology, Wuhan 430063, Hubei, China)

Received:2019-03-01 Revised:2019-03-01 Online:2020-02-22

摘要/Abstract

摘要： 为研究梯恩梯(TNT)爆炸产物的燃烧释放能量对密闭空间中的爆炸载荷增强效应，开展7.50 g、11.25 g、15.00 g、22.50 g、30.00 g 5种不同质量的TNT分别在空气和氦气环境（抑制燃烧）密闭空间中的爆炸试验。通过压力、温度传感器及三维数字图像相关技术，得到爆炸载荷历程、准静态压力、封闭空间内气体温度、金属板试件的动态响应和最终变形等试验数据。对试验结果的分析和对比发现：TNT爆炸产物的燃烧效应对封闭舱室内的爆炸载荷与结构响应影响显著，5种不同质量TNT在氦气环境中爆炸的准静态压力、温度峰值相较对应的空气工况中的降幅分别在38.81%~46.85%和57.53%~76.35%；试件最终变形较空气工况的降幅在19.1%~48.9%；建议在结构内爆响应的计算评估中应考虑爆炸载荷燃烧增强效应的影响。

关键词: 舱室密闭空间, 爆炸载荷, 燃烧效应, 准静态压力

Abstract: In order to investigate the afterburning enhancement effect of detonation products for the blast load in a confined space, the explosion experiments of 5 different masses of TNT were performed in the confined spaces filled with air and helium. The data about shockwave-time history, quasi-static pressure, temperature of mixed gas in a confined space, and both the dynamic response and final deformation of steel plates were recorded by using the pressure and temperature sensors and the three-dimensional digital image correlation (DIC) method. The experimental results were analyzed and compared. The results show that the afterburning of detonation products of TNT has a dramatic influence on the confined blast load and the structural responses. The quasi-static pressures and temperature peaks of the five different masses of TNT explosions in helium environment are reduced by 38.81%-46.85% and 57.53%-76.35%, respectively, and the final deformation of tested specimens are decreased by 19.1%-48.9% compared with those of TNT explosions in air environment. It is suggested that the afterburning enhancement effect of detonation products for the confined blast load should be taken into account in predicting the dynamic responses of structures. Key

Key words: confinedcompartmentspace, blastload, afterburningeffect, quasi-staticpressure

中图分类号:

O383⁺.3

孔祥韶，况正，郑成，吴卫国. 舱室密闭空间中爆炸载荷燃烧增强效应试验研究[J]. 兵工学报, 2020, 41(1): 75-85.

KONG Xiangshao, KUANG Zheng, ZHENG Cheng, WU Weiguo. Experimental Study of Afterburning Enhancement Effect for Blast Load in Confined Compartment Space[J]. Acta Armamentarii, 2020, 41(1): 75-85.

参考文献

［1］朱锡, 张振华, 梅志远, 等. 舰船结构毁伤力学[M]. 北京: 国防工业出版社, 2013.
ZHU X, ZHANG Z H, MEI Z Y, et al. Damage mechanics of warship structure subjected to explosion [M]. Beijing: National Defense Industry Press, 2013. (in Chinese)
[2］ RICHARD G A, JASON T D, JOSEPH S, et al. Quantitative distinction between detonation and afterburn energy deposition using pressure-time histories in enclosed explosions[C]∥Proceedings of the 13th International Detonation Symposium. Norfolk, VA, US: Office of Naval Research, 2006.
[3］胡宏伟, 宋浦, 赵省向, 等. 有限空间内部爆炸研究进展[J]. 含能材料, 2013, 21(4): 539-546.
HU H W, SONG P, ZHAO S X, et al. Progress in explosion in confined space[J]. Chinese Journal of Energetic Materials, 2013, 21(4): 539-546. (in Chinese)
[4］ ORNELLAS L D. Calorimetric determination of the heat and products of detonation of an unusual CHNOFS explosive [J]. Propellants, Explosives, Pyrotechnics, 1989, 14(3): 122-123.
[5］ FERGUSON R E, KUHL A L, OPPENHEIM A K. Combustion of TNT products in a confined explosion[C]∥Proceedings of the 17th International Colloquium on Dynamics of Explosionsand Reactive Systems. Heidelberg, Germany: Lawrence Livermore National Laboratory, 1999:1-5.
[6］ KUHL A L, REICHENBACH H. Combustion effects in confined explosions[J]. Proceedings of the Combustion Institute, 2009, 32(2): 2291-2298.
[7］ KUHL A L, BELL J B, BECKNER V E, et al. Spherical combustion clouds in explosions[J]. Shock Waves, 2013, 23(3): 233-249.
[8］ KUHL A L, BELL J B, BECKNER V E, et al. Numerical simulations of thermobaric explosions[C]∥Proceedings of the 37th
International Annual Conference Energetic Materials Characterisation and Performance of Advanced Systems. Karlsruhe, Germany: Lawrence Livermore National Laboratory, 2007:1-12.
[9］ KUHL A L, BELL J B, BECKNER V E, et al. Gasdynamic model of turbulent combustion in TNT explosions[J]. Proceedings of the Combustion Institute, 2011, 33(2): 2177-2185.

[10］ KUHL A L, OPPENHEIM A K, FERGUSON R E. Multi-fluid model of exothermic fields in explosions[C]∥Proceedings of the 12th All-Union Symposium on Combustion and Explosion. Chernogolovka, Russia: Lawrence Livermore National Laboratory, 2000:1-4.
[11］金朋刚, 郭炜, 任松涛, 等. TNT密闭环境中能量释放特性研究[J]. 爆破器材, 2014, 43(2): 10-14.
JIN P G, GUO W, REN S T, et al. Research on TNT energy release characteristics in enclosed condition[J]. Explosive Materials, 2014, 43(2): 10-14.(in Chinese)
[12］金朋刚, 郭炜, 王建灵, 等. 密闭条件下TNT的爆炸压力特性[J]. 火炸药学报, 2013, 36(3): 39-41.
JIN P G, GUO W, WANG J L, et al. Explosion pressure characteristics of TNT under closed condition[J]. Chinese Journal of Explosives and Propellants, 2013, 36(3): 39-41.(in Chinese)
[13］钟巍, 田宙. 考虑产物化学反应影响的约束爆炸准静态压力数值计算方法[J]. 爆炸与冲击, 2013, 33(增刊1): 78-83.
ZHONG W, TIAN Z. Numerical calculation of quasi-static pressures of confined explosions considering chemical reactions kinetic of detonation products [J].Explosion and Shock Waves, 2013, 33(S1): 78-83. (in Chinese)
[14］钟巍, 田宙. 等压假设下考虑化学反应动力学影响的约束爆炸准静态压力的计算[J]. 爆炸与冲击, 2013, 33(4): 375-380.
ZHONG W, TIAN Z. Calculation of quasi-static pressures for confined explosions considering chemical reactions under isobaric assumption [J].Explosion and Shock Waves, 2013, 33(4): 375-380. (in Chinese)
[15］王等旺, 张德志, 李焰, 等. 爆炸容器内准静态气压实验研究[J]. 兵工学报, 2012, 33(12): 1493-1497.
WANG D W, ZHANG D Z, LI Y, et al. Experiment investigation on quasi-static pressure in explosion containment vessels[J]. Acta Armamentarii, 2012, 33(12): 1493-1497. (in Chinese)
[16］张玉磊, 苏健军, 李芝绒, 等. TNT内爆炸准静态压力特性[J]. 爆炸与冲击, 2018, 38(6): 1429-1434.
ZHANG Y L, SU J J, LI Z R, et al. Quasi-static pressure characteristic of TNT’s internal explosion [J]. Explosion and Shock Waves, 2018, 38(6): 1429-1434. (in Chinese)
[17］张玉磊, 李芝绒, 蒋海燕, 等. 温压炸药内爆炸压力特性及威力试验研究[J]. 兵工学报, 2018, 39(7): 1333-1338.
ZHANG Y L, LI Z R, JIANG H Y, et al. Experimental study of the characteristics of internal explosion pressure and power of thermobaric explosive[J]. Acta Armamentarii, 2018, 39(7): 1333-1338.(in Chinese)
[18］ FELDGUN V R, KARINSKI Y S, EDRI I, et al. Prediction of the quasi-static pressure in confined and partially confined explosions and its application to blast response simulation of flexible structures[J]. International Journal of Impact Engineering, 2016, 90: 46-60.
[19］ NURICK G N, MARTIN J B. Deformation of thin plates subjected to impulsive loading—a review part Ⅱ: experimental studies［J］. International Journal of Impact Engineering, 1989,8(2): 171-186.
[20］ CHUNG K Y S, NURICK G N, LANGDON G S, et al. Deformation of thin plates subjected to impulsive load: part Ⅲ - an update 25 years on[J]. International Journal of Impact Engineering, 2017, 107:108-117.
[21］ ZHAO Y P, YU T X, FANG J. Large dynamic plastic deflection of a simply supported beam subjected to rectangular pressure pulse[J]. Archive of Applied Mechanics, 1994, 64(3):223-232.
[22］ ZHAO Y P, YU T X, FANG J. Saturation impulses for dynamically loaded structures with finite-deflections [J]. Structural Engineering & Mechanics, 1995, 3(6):583-592.
[23］孔祥韶, 周沪, 郑成, 等. 基于饱和响应时间的封闭空间内爆炸载荷等效方法研究[J]. 爆炸与冲击, 2019,39(9):092102.
KONG X S,ZHOU H, ZHENG C, et al. An equivalent calculation method for confined-blast load based on saturated response time[J]. Explosion and Shock Waves, 2019,39(9):092102.

第41卷第1期
2020 年1月兵工学报ACTA
ARMAMENTARIIVol.41No.1Jan.2020

[1]	刘正, 聂建新, 徐星, 朱英中, 刘攀, 郭学永, 闫石, 张韬. 密闭空间内六硝基六氮杂异伍兹烷基复合炸药能量释放特性[J]. 兵工学报, 2022, 43(3): 503-512.
[2]	李明星，张明，陈四春，李锴，刘状，袁溪. 爆炸载荷冲击下假人下肢的材料参数识别和修正方法[J]. 兵工学报, 2021, 42(9): 1895-1901.
[3]	禹富有，董新龙，俞鑫炉，付应乾. 不同填塞装药下金属柱壳断裂特性的实验研究[J]. 兵工学报, 2019, 40(7): 1418-1424.
[4]	王传昊，王树山，张静骁，魏继锋. 舱室内爆炸压力载荷测试方法研究[J]. 兵工学报, 2019, 40(5): 1003-1010.
[5]	孔祥韶，徐敬博，徐维铮，郑成，吴卫国. 舱室密闭空间中爆炸载荷后燃烧效应数值计算研究[J]. 兵工学报, 2019, 40(4): 799-806.
[6]	郑成，孔祥韶，周沪，徐维铮，吴卫国. 全封闭舱内爆炸载荷作用下薄板变形研究[J]. 兵工学报, 2018, 39(8): 1582-1589.
[7]	张玉磊，李芝绒，蒋海燕，翟红波，袁建飞，仲凯. 温压炸药内爆炸压力特性及威力试验研究[J]. 兵工学报, 2018, 39(7): 1333-1338.
[8]	张晓颖，李胜杰，李志强. 爆炸载荷作用下夹层玻璃动态响应的数值模拟[J]. 兵工学报, 2018, 39(7): 1379-1388.
[9]	陈鹏宇，侯海量，刘贵兵，朱锡，张国栋. 水雾对舱内装药爆炸载荷的耗散效能试验研究[J]. 兵工学报, 2018, 39(5): 927-933.
[10]	何成龙，杨军. 主动围压和爆炸加载作用下岩石动态响应研究[J]. 兵工学报, 2017, 38(12): 2395-2405.
[11]	顾紅军，赵国志，殷克功. 爆炸载荷作用下钢管拼装结构大变形模态解[J]. 兵工学报, 2005, 26(3): 357-361.
[12]	1:陈放;2:马晓青，王鹏. 爆炸变形定向战斗部壳体变形分析[J]. 兵工学报, 2004, 25(6): 757-760.

舱室密闭空间中爆炸载荷燃烧增强效应试验研究

Experimental Study of Afterburning Enhancement Effect for Blast Load in Confined Compartment Space

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 12

编辑推荐

Metrics

本文评价